Numerical simulation and test of performance of deep-well centrifugal pumps with different stages
SHI Weidong 1,2*, HOU Yunhe 1, ZHOU Ling 1, LI Yuemin 3, XUE Shaohui 3
1. National Research Center of Pumps, Jiangsu University, Zhenjiang, Jiangsu 212013, China; 2. School of Mechanical Engineering, Nantong University, Nantong, Jiangsu 226019, China; 3. Shanxi Skysea Pump Limited, Yuncheng, Shanxi 044000, China
Abstract：A deep-well centrifugal pump of type 250QJ80 was chosen to be study model and features of the pump performance at different numbers of stages were explored numerically and experimentally, further the root causes for these features were clarified in terms of analysis of internal flow field in the pump. In the paper, software ANSYS-CFX 17.0 was used to carry out numerical predictions on the pump performance based on three pump models with single stage, two stages and three stages, respectively. The computational domain of three models has experienced geometrical modelling and structured-mesh creation, then the water flow field in these models were simulated under a few working conditions based on the standard k-ε turbulence model and standard wall function. The predicted performance of these models was obtained, compared and analyzed against the corresponding experimental data. The results show that the change in pump stages doesn′t affect the performance of the pump with a specific number of stages. However, the head and efficiency of the first stage are higher than those of the se-cond or third stages, while the head and efficiency of the second stage doesn′t differ obviously from the third stage. The main reason for this similarity and difference in the head and efficiency is that the impeller of the first stage is without any pre-swirl, while the impellers of the rest stages are subject to a certain amount of pre-swirl.
施卫东,*,侯云鹤,周岭,李跃民,薛少辉. 不同级数深井离心泵性能的数值模拟与试验[J]. 排灌机械工程学报, 2019, 37(7): 562-567.
SHI Weidong ,*, HOU Yunhe , ZHOU Ling , LI Yuemin , XUE Shaohui . Numerical simulation and test of performance of deep-well centrifugal pumps with different stages. Journal of Drainage and Irrigation Machinery Engin, 2019, 37(7): 562-567.
[1]施卫东,王洪亮,余学军,等. 深井泵的研究现状与发展趋势[J]. 农机化研究, 2009, 27(1):74-76. SHI Weidong, WANG Hongliang, YU Xuejun, et al. Research status and development trend of deep well pump[J]. Journal of agricultural mechanization research, 2009, 27(1):74-76.(in Chinese)[2]ZHOU L, SHI W, WU S. Performance optimization in a centrifugal pump impeller by orthogonal experiment and numerical simulation[J]. Advances in mechanical engineering, 2013(1):31-41.[3]曹宁, 高莹, 马斌. 末级密封间隙对自平衡多级离心泵性能的影响[J]. 流体机械, 2018, 46(6):22-26. CAO Ning, GAO Ying, MA Bin, et al. Effect of final-stage seal clearance on performance of self-balancing multistage centrifugal pump[J].Fluid machinery,2018, 46(6):22-26.(in Chinese)[4]张霞,袁寿其,张金凤,等.不同叶片包角对螺旋形单蜗壳离心泵叶轮径向力特性的影响[J].流体机械,2017,45(1):43-47. ZHANG Xia,YUAN Shouqi,ZHANG Jinfeng,et al. Effect of different blade wrap angle on impeller radial force for a hedical single spiral volute centrifugal pump[J].Fluid machinery,2017,45(1):43-47.(in Chinese)[5]黄思, 桑迪科. 多级离心泵三维流场数值模拟及性能预测[J]. 机械科学与技术, 2010, 29(6):705-708. HUANG Si, SANG Dike. Numerical simulation of the three-dimensional flow field in a multistage centrifugal pump and its performance prediction[J]. Mechanical science & technology for aerospace engineering, 2010, 29(6):705-708.(in Chinese)[6]周岭, 白玲, 杨阳,等. 导叶叶片数对井用潜水泵性能的影响[J]. 农业机械学报, 2016, 47(10):78-84. ZHOU Ling, BAI Ling, YANG Yang, et al. Influence of diffuser vane number on submersible well pump perfor-mance[J]. Transactions of the CSAM, 2016, 47(10): 78-84.(in Chinese)[7]施卫东,杨阳,周岭,等. 潜水泵缩比模型的相似性验证与内部流场分析[J].农业工程学报, 2017, 33(3):50-57. SHI Weidong, YANG Yang, ZHOU Ling, et al. Verification of comparability and analysis of inner flow fields on scaling models of submersible well pump[J].Tran-sactions of the CSAE, 2017, 33(3):50-57.(in Chinese)[8]SHUKLA S N, KSHIRSAGAR J T. Numerical experiments on a centrifugal pump[C]// Proceedings of the ASME 2002 Joint U.S.-European Fluids Engineering Division Conference, 2002:709-719.[9]MENTER F R. Two-equation eddy-viscosity turbulence models for engineering applications[J].AIAA joumal,1994,32(8):1598-1605.[10]苗森春, 杨军虎, 王晓晖,等. 叶片数对泵作液力透平的性能影响[J]. 流体机械, 2018,46(1):1-5. MIAO Senchun,YANG Junhu,WANG Xiaohui,et al. Effect on blade number on performance of pump as turbine[J].Fluid machinery,2018,46(1):1-5.(in Chinese)
