Abstract：A flow-field analysis model of the mixed-flow pump was established in order to study the flow field and pressure pulsation characteristics under different operating conditions. The unsteady numerical simulation of the whole flow field under different operating conditions was carried out by Large eddy simulation(LES)based on the CFX software. The results showed that the flow pattern was consis-tent at six channels except that a certain flow separation appeared on the suction surface near the guide vanes outlet at 1.00Qopt. When the rotating stall occurred, a lot of whirlpool developed near the suction surface of the guide vanes and the whirlpool scale increased first and then decreased from the inlet to the outlet at the guide vanes,more over the vortex core was attached to the suction surface where the pressure fluctuation was smallest. The pressure pulsationat different points was analyzed by FFT transform, which showed that the amplitude of the pressure pulsation increased graduallyfrom the hub to the rim. The distributiom of the pressure pulsation frequency at the outlet was similar to that at the inlet except that the amplitude decreased a little and the dominant frequency shifted to the low-frequency direction.Additionally, the pressure pulsation under different operating conditions was also analyzed. The changing regularity of three operating conditions was consistent.However, the frequency range is larger and the frequency components are more complex at 0.55Qoptcondition than at 0.75Qoptand 1.00Qopt condition. At 0.75 Qopt the low-frequency width is significantly reduced and the frequency of low-frequency pulsation was concentrated around 1N,white at 1.00Qopt,the frequency was not obvious except 6N and 12N, the amplitude of the pulsation frequency in the low-frequency range was significantly reduced, and the integral pulsation amplitude was significantly smaller than that under the other two operating conditions.
张琳, 施卫东, 张德胜, 石磊. 基于大涡模拟的混流泵不稳定流动数值研究[J]. 排灌机械工程学报, 2017, 35(4): 303-308.
ZHANG Lin, SHI Weidong, ZHANG Desheng, SHI Lei. Analysis of instability flow on mixed-flow pump based on LES. Journal of Drainage and Irrigation Machinery Engin, 2017, 35(4): 303-308.
[1]关醒凡. 轴流泵和斜流泵[M]. 北京:中国宇航出版社,2009.[2]AGOSTINELLI A, NOBLES D, MOCKRIDGE C R. An experimental investigation of radial thrust in centrifugal pumps[J]. Journal of engineering for gas turbines & power, 1960, 82(2):120-125.[3]IVERSEN H W, ROLLING R E, CARLSON J J. Volute pressure distribution, radial force on the impeller, and volute mixing losses of a radial flow centrifugal pump[J]. Journal of engineering for gas turbines & power, 1960, 82(2):136-143.[4]HERGT P, KRIEGER P, HERGT P, et al. Radial forces in centrifugal pumps with guide vanes[J]. 1969, 184(314):101-107.[5]UCHIDA N, IMAICHI K, SHIRAI T. Radial force on the impeller of a centrifugal pump[J]. Bulletin of JSME, 1971, 14(76):1106-1117.[6]CHAMIEH D S, ACOSTA A J, BRENNEN C E, et al. Experimental measurements of hydrodynamic radial forces and stiffness matrices for a centrifugal pump-impeller[J]. Journal of fluids engineering, 1985, 107(3):307-315.[7]BRAUN O. Part load flow in radial centrifugal pumps[D]. Lausanne:EPFL, 2009.[8]王福军, 张玲, 张志民. 轴流泵不稳定流场的压力脉动特性研究[J]. 水利学报,2007, 38(8):1003-1009. WANG Fujun, ZHANG Ling, ZHANG Zhimin.Study on pressure fluctuation of unsteady flow field of axial flow pump [J]. Journal of hydraulic engineering, 2007,38(8): 1003-1009.(in Chinese) [9]MIORINI R L, WU H, TAN D, et al. Three-dimensional structure and turbulence within the tip leakage vortex of an axial waterjet pump[C]//Proceedings of ASME-JSME-KSME 2011 Joint Fluids Engineering Conference. New York:ASME, 2011:271-281.[10]潘中永,李俊杰,李晓俊,等. 斜流泵不稳定特性及旋转失速研究[J]. 农业机械学报,2012, 43(5):64-68. PAN Zhongyong, LI Junjie, LI Xiaojun. Instability characteristics and rotational stall of a mixed flow pump [J].Transactions of the CSAM, 2012, 43(5): 64-68.(in Chinese)[11]何秀华. 水泵叶频压力脉动形成的机理探讨[J]. 机械设计与制造工程, 1996,25(6):38-39. HE Xiuhua. The discussion on the mechanism of pressure fluctuation of water pump[J].Mechanical science and technology, 1996,25(6):38-39.(in Chinese)[12]邹萍萍. 高比转速斜流泵内部压力脉动特性研究[D]. 镇江:江苏大学, 2011.[13]施卫东, 邹萍萍, 张德胜,等. 高比转速斜流泵内部非定常压力脉动特性[J]. 农业工程学报, 2011, 27(4):147-152. SHI Weidong, ZOU Pingping, ZHANG Desheng. The unsteady pressure pulsation characteristics of high specific speed mixed flow pump [J]. Transactions of the CSAE, 2011, 27(4): 147-152.(in Chinese)
