Abstract:In order to research the effect of pressure fluctuation caused by complicated flow inside centrifugal pumps at shut-off condition,based on the virtual technology and LabView,the pressure signal of centrifugal pumps was decomposed and the wavelet packet analysis was applied to extract the feature spectrum and establish different frequency bands.The experiment was carried out to test the analysis results.The analysis results show that the pressure pulsation at shut-off condition is irregular and non-cyclical,and low-frequency pulsation plays an important role.With the flow decreases,the amplitude of the shaft frequency first increases and then decreases.Backflow appears when centrifugal pumps operate at low flow rate to shut-off condiftions and the wavelet packet reconstruction coefficient changes,and it could be concluded that backflow exert significant influence at low frequency.The amplitude and strength at shut-off condition with enhancement on shaft frequency.The inlet backflow of centrifugal pumps at shut-off condition is braided backflow.The validating test results show that different frequency corresponding to different unsteady flow can be identified based on wavelet packet,which will improve the diagnosis of the inner flow of centrifugal pumps at shut-off condition.
[1]袁寿其 ,付强 ,朱荣生.核电站离心式上充泵多工况水力没计[J].排灌机械工程学报,2010,28(5):185-l89.[2]Dyson G. A review of closed valve head prediction methods for centriflagal pumps [ J ]. Journal of Power and Energy,2002,216(4) :329 - 337.[3]Newton T M. Rotor-stator interaction in radial flow pumps and fans at shut-off condition [ D ]. United King- dora, Newcastle : Newcastle University, 1998.[4]Dyson G,Teixeira J. Investigation of closed valve opera- tion using computational fluid dynamics [ C ] //Procee-dings of the 2009 ASME Fluids Engineering Division Summer Meetings, 2009 : 78021.[5]Guo Shijie, Okamoto Hidenobu. An experimental study on the fluid forces induced by rotor-stator interaction in a centrifugal pump [ J ]. International Journal ~f Rotating Machinery, 2003,9 ( 2 ) : 135 - 144.[6]Berten S, Dupont P, Fabre L, et al. Experimental investi- gation of flow instabilities and rotating stall in a high-energy centrifugal pump stage [ C ] //Proceedings of the 2009 ASME Fluids Engineering Diuision Summer Mee- tings, 2009 : 78562.[7]韩清凯,于晓光.基于振动分析的现代机械故障诊断原理及应用[M].北京:科学出版社,2010..[8]诸福磊.机械故障诊断中的现代信号处理方法[M].北京:科学出版社,2009..[9]倪永燕.[D].镇汀:汀苏大学流体机械工程技术研究中心,2008.[10]黄忠富.[D].镇汀:江苏大学流体机械工程技术研究中心,2008.[11]何正嘉,訾艳阳 张两宁.现代信号处理及工徉应川[M].两安:两安交通大学出版社,2007..[12]高英杰,孔祥东 ZHANGQ.基于小波包分析的液压泵状态监测方法[J].机械工程学报,2009,45(8):80-88.