bearing rigidity on characterisitics of natural vibration of shaft system in hydroturbine generating unit
BAI Bing, ZHANG Li-Xiang, ZHAO Lei
(1. Department of Engineering Mechanics, Kunming University of Science and Technology, Kunming, Yunnan 650051, China; 2. The First Research Institute of 134 Department of Xinhang Military Company, Xinxiang, Henan 453049, China)
Abstract:To study the characteristics of the lateral natural vibration of the main shaft system in hydroturbine generating unit, with the finite element method the main shaft system was discretized; and with energy method the dynamic equation was obtained. Based on simplified actual parameters, with MATLAB software, fixed frequencies, mode shapes and critical speed of rotation of the shaft system were calculated and influences on critical speed caused by changes in the guide bearing rigidity were analyzed. The results show that when only one guidebearing rigidity is changed, up guidebearing has little influence on critical speed; however, the down bearing and the water guidebearing greatly affect the critical speed. There occurs a “saturated” phenomenon, that is to say, the critical speed remains unchanged when the rigidity reaches or exceeds a certain value. If the rigidity of the three guidebearings is increasing simultaneously, the critical speed can be increased significantly. Change in the up guidebearing has little effect on the modes in the first three orders; Change in the down guidebearing and water guidebearing will result in an opposite mode in a certain mode. It can be concluded that it is necessary to fully consider the effect caused by the guidebearing rigidity in evaluating the critical speed of the shaft system.
白冰, 张立翔, 赵磊. 导轴承刚度对水轮机轴系自振特性的影响[J]. 排灌机械工程学报, 2013, 31(4): 318-324.
BAI Bing, ZHANG Li-Xiang, ZHAO Lei. bearing rigidity on characterisitics of natural vibration of shaft system in hydroturbine generating unit. Journal of Drainage and Irrigation Machinery Engin, 2013, 31(4): 318-324.
[1]马震岳,董毓新.水轮发电机组动力学[M].大连:大连理工大学出版社,2003.[2]宋志强,马震岳,张运良,等.考虑厂房基础耦联作用的水轮发电机组轴系统动力反应分析[J].振动与冲击,2008,27(6):158-161.Song Zhiqiang, Ma Zhenyue,Zhang Yunliang, et al. Dynamic response analysis of rotorbearing system of a generator set according for whole hydropower housing foundation [J]. Journal of Vibration and Shock, 2008, 27 (6): 158-161.(in Chinese)[3]杨志安,李文兰,邱家俊.发电机组轴系电磁激发横扭耦合振动[J].天津大学学报,2008,41(5):583-588.Yang Zhian, Li Wenlan, Qiu Jiajun. Lateral and torsional coupling vibration excited by electromagnetism of turbogenerator set rotor system[J]. Journal of Tianjin University, 2008,41(5):583-588.(in Chinese)[4]李兆军,杨旭娟,蔡敢为,等.水轮发电机组主轴系统的水流激励特性[J].排灌机械工程学报,2011,29(5):423-426,431.Li Zhaojun,Yang Xujuan, Cai Ganwei, et al.Hydraulic excitation exerting on main shaft system of hydraulic turbinegenerator units[J]. Journal of Drainage and Irrigation Machinery Engineering, 2011, 29(5): 423-426, 431. (in Chinese)[5]Hosseini S A A, Khadem S E. Free vibrations analysis of a rotating shaft with nonlinearities in curvature and inertia [J]. Mechanism and Machine Theory, 2009,44(1):272-288.[6]Zhang Lixiang, Guo Yakun, Zhang Hongming. Fully coupled flowinduced vibration of structures under small deformation with GMRES method [J]. Applied Mathematics and Mechanics: English Edition, 2010, 31(1): 87-96.[7]Momcilovic Dejan, Odanovic Zoran, Mitrovic Radivoje, et al. Failure analysis of hydraulic turbine shaft [J]. Engineering Failure Analysis, 2012, 20: 54-66.[8]Saeed R A, Galybin A N, Popov V. 3D fluidstructure modeling and vibration analysis for fault diagnosis of Francis turbine using multiple ANN and multiple ANFIS [J]. Mechanical Systems and Signal Processing, 2012, 34(1/2):259-276.[9]Saeed R A, Galybin A N, Popov V. Modelling of flowinduced stresses in a Francis turbine runner [J]. Advances in Engineering Software, 2010,41(12):1245-1255.[10]Xiao Ruofu, Wang Zhengwei, Luo Yongyao. Dynamic stresses in a francis turbine runner based on fluidstructure interaction analysis [J]. Tsinghua Science and Technology, 2008, 13(5):587-592.[11]钟一谔,何衍宗,王正,等. 转子动力学[M].北京:清华大学出版社,1987.[12]蔡敢为,张永辉,马存志,等.混流式水轮发电机组主轴系统振动特性分析[J].计算机辅助工程,2008,17(3):1-4.Cai Ganwei, Zhang Yonghui, Ma Cunzhi, et al. Vibration characteristics analysis on main shaft system of Francis waterturbine generator set[J]. Computer Aided Engineering, 2008, 17(3):1-4.(in Chinese)[13]赵磊,张立翔.水轮发电机转子轴系电磁激发横-扭耦合振动分析[J].中国农村水利水电,2010(3): 136-139.Zhao Lei, Zhang Lixiang. Lateraltorsional coupling vibration of rotor system of hydroturbine generator unit in electromagnetic transitional condition[J]. China Rural Water and Hydropower, 2010(3): 136-139.(in Chinese)[14]Wang Fujun,Li Xiaoqin, Ma Jiamei, et al. Experimental investigation of characteristic frequency in unsteady hydraulic behaviour of a large hydraulic turbine [J]. Journal of Hydrodynamics, 2009, 21(1):12-19.[15]Huang Ruo, Ge Xinbin, Ma Chaochen. Research on the critical speed of a mixedflow turbocharger with hybrid ceramic ball bearing [J]. Journal of Beijing Institute of Technology: English Edition, 2009, 18(3):298-303.