Abstract:In order to study the influence of droplet′s motion and turbulent pulsation featares on the heat and mass tranfer characteristics under the effect of electrostatic forces and fluid forces in electrostatic spray two-phase flow, Particle Dynamic Analyzer was adopted to measure the electrostatic spray two-phase flow. The relationship of droplets diameter distributions, velocity and turbulent pulsating intensity with voltages were gained for various gas liquids ratios. The droplets whose diameter is less than 10 μm was regarded as continuous phase, and the other droplets was considered as discrete one. The gas-droplets two-phase fluid information was obtained. The experiment data indicate that the droplets diameter reduces with voltages incresing, and the droplets velocity is according with the gas and is unchangeable under different voltages. The droplets turbulent pulsating intensity is differ from continuous phase, and the droplets have produced much more pulsating than continuous phase in electrostatic field.
[1]Hideo W,Tatsushi M,Hideo Y.Experimental study on electrostatic atomization of highly viscous liquids[J].Journal of Electrostatics,2003,57(5):183-187.[2]Law S E.Agricultural electrostatic spray application:a review of significant research development during the 20th century[J].Journal of Electrostatics,2001,51-52(5):25-42.[3]王贞涛,岑旗钢,宋晓宁,等.双流体荷电雾化的PDA实验[J].农业机械学报,2008,39(10):80-84.Wang Zhentao,Cen Qigang,Song Xiaoning,et al.The experimental research of twin-fluid charged spray by PDA[J].Transactions of the Chinese Society for Agricultural Machinery,2008,39(10):80-84.(in Chinese)[4]亢燕铭,李世龙.荷电喷雾脱硫实验与机理分析[J].环境科学学报,2001,21(5),538-543.Kang Yanming,Li Shilong.Experimental and theoretical analysis of flue gas desulfurization by charged water and slurry droplets[J].Acta Scientiae Circumstantiae,2001,21(5):538-543.(in Chinese)[5]陶邦彦,余鸿达.吸收剂荷电、增湿活化烟气脱硫工艺的初步分析[J].动力工程,2000,20(6),919-922.Tao Bangyan,Yu Hongda.Preliminary analysis of FGD technology on absorbent charging and moistening activation[J].Power Engineering,2000,20(6):919-922.(in Chinese)[6]王贞涛.石灰浆液双流体荷电喷雾烟气脱硫理论与试验研究[D].镇江:江苏大学能源与动力工程学院,2008.[7]鲍重光.静电技术原理[M].北京:北京理工大学出版社,1993.[8]岑旗钢.静电雾化机理及雾化流场特性的实验研究[D].镇江:江苏大学能源与动力工程学院,2004.[9]Bachalo W D.Experimental methods in multiphase flows[J].International Journal of Multiphase Flow,1994,20(S1):261-295.[10]杨敏官,高波,刘栋,等.旋流泵内部盐析两相速度场的PDPA实验[J].工程热物理学报,2008,29(2):237-240.Yang Minguan,Gao Bo,Liu Dong,et al.Experimental investigation of salt-out two-phase flow in a vortex pump by PDPA measurements[J].Journal of Engineering Thermophysics,2008,29(2):237-240.(in Chinese)[11]王军锋,王贞涛,毛惠敏,等.双流体荷电喷雾结构的PIV测量[J].农业机械学报,2009,40(9):107-111.Wang Junfeng,Wang Zhentao,Mao Huimin,et al.Measurement of twin-fluid electrostatic spray structure by using PIV[J].Transactions of the Chinese Society for Agricultural Machinery,2009,40(9):107-111.(in Chinese)