|
|
Several typical transient processes of pump turbine |
Liu Kaihua, Zhang Yuning, Xian Haizhen |
Key Laboratory of Condition Monitoring and Control for Power Plant Equipment, North China Electric Power University, Beijing 102206, China |
|
|
Abstract In order to study the negative effects of abnormal transient processes on the pump turbine and the corresponding improved measures, the inherent feature of performance curve of the pump turbine(named S-shaped characteristics),together with the recent research progress in several typical transient processes of the pump turbine, is introduced. The S-shaped characteristics shown in the performance curve of the pump turbine along the guide vane opening line are briefly introduced, with its physical origins and negative effects. A detailed introduction to the hysteresis phenomenon of the pump turbine is performed and it is found that the present discharge of pump turbine at the fixed rotational speed is not a unique value because the operational condition of the pump turbine depends not only on the current input of the system but also on the history of the system and hence the hysteresis phenomenon leads to the drop of water head,low efficiency, vibrations and noise. The generation condition of the hysteresis phenomenon, the influence of rotational speed and the improved methods based on changing runner inlet and outlet angles are set forth. Measurement of the dynamic stress on the shaft and influences of the rotor-stator interaction on the measured signal analysis are both elaborated,giving the corresponding phenomena, basic characteristics and paramount influencing parameters. The instability of the pump turbine working with no load at start-up as well as the instability at the guide vanes closure, and the solutions to them are also expounded. Mereover, the advantage and the disadvantage of different methods are compared.
|
Received: 09 February 2015
|
|
|
|
[1]何少润. 导叶不同步装置在天荒坪抽水蓄能电站的应用[J]. 水力发电学报,2002, 21(3):88-99. He Shaorun. The apply of MGV device in Tianhuangping pumped storage power station [J]. Journal of Hydroelectric Engineering, 2002, 21(3):88-99.(in Chinese)[2]杨洪涛.天堂蓄能电厂机组开机不成功故障分析与处理[J].水电站机电技术,2002,25(3):21-23. Yang Hongtao.The analysis and processing of the failure on unsuccessful start up of Heaven pumped storage power plant[J].Mechanical and Electrical Technique of Hydropower Station,2002,25(3):21-23.(in Chinese)[3]王洋,王玲花.水电站过渡过程研究历史及现状综述[J].吉林水利,2014,34(9):29-33. Wang Yang,Wang Linghua. Summary of research history and current situation for transient process of hydropower station[J]. Jilin Water Resources,2014,34(9):29-33.(in Chinese)[4]李金伟.大型混流可逆式水泵水轮机的S形特性研究[D].北京:中国水利水电科学研究院水利研究所,2011.[5]梅祖彦.抽水蓄能发电技术[M].北京:机械工业出版社, 2000:202.[6]徐广文. “S” 特性对可逆式机组低水头发电并网影响的分析及对策[EB/OL]. [2014-10-09].http://www.paper.edu.cn.[7]周嘉元, 郑慧娟.水泵水轮机的 “S” 形特性对机组性能的影响[J]. 中国农村水利水电, 2006,48(2): 111-113. Zhou Jiayuan, Zheng Huijuan. The influence of the S- shaped characteristics on a pump unit performance [J]. China Rural Water and Hydropower, 2006,48(2): 111-113.(in Chinese)[8]蔡军,周喜军,邓磊,等.江苏宜兴抽水蓄能电站3号机组过速试验异常水击现象的研究[J].水力发电,2009,35(2): 76-79. CaiJun, Zhou Xijun, Deng Lei,et al. The research of the abnormal water hammer phenomenon based on the unit 3 over speed test of Jiangsu Yixing pumped storage power station[J].Water Power, 2009,35(2): 76-79.(in Chinese)[9]郑冬飞,易忠有.张河湾抽水蓄能电站水泵水轮机主要参数研究[C]// 中国水力发电工程学会电网调峰与抽水蓄能专业委员会.抽水蓄能电站工程建设文集. 北京:中国电力出版社,2008.[10]Yamabe M.Hysteresis characteristics of Francis pump-turbines when operated as turbine[J]. Journal of Fluids Engineering, 1971, 93(1): 80-84.[11]Olimstad G, Nielsen T, B rresen B. Stability limits of reversible-pump turbines in turbine mode of operation and measurements of unstable characteristics[J]. Journal of Fluids Engineering, 2012, 134(11): 1-8.[12]Ran H J, Luo X W, Chen Y L, et al. Hysteresis phenomena in hydraulic measurement[C]//IOP Conference Series: Earth and Environmental Science. [S.l]:IOP Publishing, 2012.[13]Ran H, Luo X, Zhu L, et al. Experimental study of the pressure fluctuations in a pump turbine at large partial flow conditions[J]. Chinese Journal of Mechanical Engineering, 2012, 25(6): 1205-1209.[14]Zhang Xiaoxi, Cheng Yanbo, Xia Likun, et al. Dyna-mic characteristics of a pump-turbine during hydraulic transients of a model pumped-storage system: 3D CFD simulation[C]//IOP Conference Series: Earth and Environmental Science. [S.l]:IOP Publishing, 2014, 22(3): 032030.[15]Yamabe M. Improvement of hysteresis characteristics of Francis pump-turbines when operated as turbine[J]. Journal of Fluids Engineering, 1972, 94(3): 581-585.[16]Ha H C. Preload effects of a guide bearing on the metal temperature and the shaft vibration[J]. Journal of Tribology, 2001, 123(1): 144-150.[17]Rodriguez C G, Egusquiza E, Santos I F. Frequencies in the vibration induced by the rotor stator interaction in a centrifugal pump turbine[J]. Journal of Fluids Engineering, 2007, 129(11): 1428-1435.[18]Rodriguez C G, Mateos Prieto B, Egusquiza E. Monitoring of rotor-stator interaction in pump-turbine using vibrations measured with on-board sensors rotating with shaft[J]. Shock and Vibration, 2014(1):1-8.[19]Jean-Bernard H, 刘杰,Sylvainet L,等.高水头可逆式水泵水轮机水轮机工况起动[C]// 中国动力工程学会水轮机专业委员会.第十九次中国水电设备学术讨论会论文集. 哈尔滨:黑龙江科学技术出版社出版,2013.[20]Guggenberger M, Senn F, Schiffer J, et al. Experimental investigation of the turbine instability of a pump-turbine during synchronization[C]//IOP Conference Series: Earth and Environmental Science. [S.l]: IOP Publishing, 2014, 22(3): 15-26.[21]孙洁民,朱玉祥,韩增祥.天荒坪抽水蓄能电站1号机低水头空载稳定性的改善[J].水力发电,2001,27(6):60- 63. Sun Jiemin, Zhu Yuxiang, Han Zengxiang. Improve the stability in the low head No. 1 machine at no load operation of Tianhuangping pumped storage power plant [J]. Water Power, 2001,27(6):60-63.(in Chinese)[22]刘锦涛.基于非线性局部时均化模型的水泵水轮机“S”区稳定性分析[D].浙江:浙江大学化学工程与生物工程学系,2013.[23]姜茜. 高水头可逆式抽水蓄能机组水轮机模式下起动的改进[J]. 东方电机, 2013, 41(6): 75-82. Jiang Qian. Starting up improvement at high head reversible pumped storage units turbine mode[J]. Dongfang Electrical Machine, 2013, 41(6): 75-82.(in Chinese)[24]Hasmatuchi V, Farhat M, Roth S, et al. Experimental evidence of rotating stall in a pump-turbine at off-design conditions in generating mode[J]. Journal of Fluids Engineering, 2011, 133(5): 4-12.[25]Klemm D. Stabilizing the characteristics of a pump- turbine in the range between turbine part load and reverse pump operation [J]. Voith Research and Construction, 1982,28(2):1-2.[26]游光华,孔令华,刘德有.天荒坪抽水蓄能电站水泵水轮机“S”形特性及其对策[J].水力发电学报,2007,25(6):136-139. You Guanghua, Kong Linghua, Liu Deyou. Pump- turbine S zone & its effect at Tianhuangping storage pump plant[J]. Journal of Hydroelectric Engineering, 2007,25(6):136-139.(in Chinese)[27]郑建兴, 张俊芝, 曾再祥, 等. 黑麋峰蓄能电站水泵水轮机模型验收试验及性能分析[J]. 水力发电, 2010, 36(7): 63-65. Zheng Jianxing, Zhang Junzhi,Zeng Zaixiang, et al.Model acceptance test and performance analysis of pump-turbine of Heimifeng pumped-storage power station[J]. Water Power, 2010, 36(7): 63-65.(in Chinese)[28]Sun Hui, Xiao Ruofu, Liu Weichao, et al. Analysis of S characteristics and pressure pulsations in a pump-turbine with misaligned guide vanes[J]. Journal of Fluids Engineering, 2013, 135(5): 1-6.[29]Liu Jintao, Liu Shuhong, Sun Yuekun,et al. Numerical simulation of pressure fluctuation of a pump-turbine with MGV at no-load condition[C]//IOP Conference Series: Earth and Environmental Science. [S.l]:IOP Publishing, 2012, 15(6): 6-14.[30]Xiao Yexiang, Xiao Ruofu. Transient simulation of a pump-turbine with misaligned guide vanes during turbine model start-up[J]. Acta Mechanica Sinica, 2014, 30(5): 646-655.[31]李君, 王磊, 廖伟丽, 等. 水泵水轮机低水头空载运行的压力脉动研究[J]. 水电能源科学, 2014,32(9): 156-159. Li Jun,Wang Lei,Liao Weili, et al. Study on pressure fluctuation of pump turbine under low head no-load operating condition[J]. Water Resources and Power,2014,32(9): 156-159.(in Chinese)[32]李君,王磊,廖伟丽.可逆式水泵水轮机“S”形区域内部流场特性分析[J].农业工程学报,2014,30(15):106-113. Li Jun,Wang Lei,Liao Weili.Internal flow characteristics analysis on S-shaped region of reversible pump-turbine[J].Transactions of the CSAE,2014,30(15):106-113.(in Chinese)[33]Landry C, Allign S, Hasmatuchi V, et al. Non-Linear stability analysis of a reduced scale model pump-turbine at off-design operation[C]//Proceedings of the 4th IAHR International Meeting on Cavitation and Dynamic Problems in Hydraulic Machinery and Systems. Belgrade:[s.n.],2011: 231-239.[34]Trivedi C, Cervantes M J, Gandhi B K, et al. Transient pressure measurements on a high head model Francis turbine during emergency shutdown, total load rejection, and runaway[J]. Journal of Fluids Engineering, 2014,136(12): 7-25.[35]郑源,张建.水力机组过渡过程[M]. 北京:北京大学出版社, 2008.[36]李小芹, 常近时, 李长胜. 改善水轮机过渡过程品质的导叶异步关闭方式[J]. 水力发电学报, 2014, 33(1): 202-206. Li Xiaoqin, Chang Jinshi, Li Changsheng. Guide vane asynchronous closure mode for improving the transient quality of hydroturbine[J]. Journal of Hydroelectric Engineering, 2014,33(1):202-206.(in Chinese)[37]李小芹,常近时,李长胜,等.抽水蓄能电站中球阀协同导叶关闭的水力瞬变过程控制方式[J].水利学报,2014,45(2):220-226. Li Xiaoqin,Chang Jinshi,Li Changsheny, et al.Hydraulic transient controlling rules coupled with ball-valve and guide-vane in pumped storage power station[J].Journal of Hydraulic Engineering,2014,45(2):220-226.(in Chinese)[38]Yu Xiaodong, Zhang Jian, Miao Di. Innovative closure law for pump-turbines and field test verification[J]. Journal of Hydraulic Engineering, 2015,141(3):10-19. |
|
|
|