Abstract：Currently, studies on aerostatic dry gas seals are mostly limited to their steady characteristics, while little attention has been paid on their unsteady characteristics, which are very important to allow the seals to have excellent operating performance so far. Hence the aerostatic dry gas film pressure governing equations and unsteady Reynolds equations are solved by using small perturbation and finite difference methods under the condition of three degrees of freedom perturbation. The influences of squeeze number, frequency number and supplying gas pressure on the unsteady characteristics are investigated. The results show that the axial direct dynamic gas film stiffness increases with increasing squeeze number, frequency number and supplying gas pressure, but the direct dynamic gas film stiffness in two angular directions is little influenced by the squeeze number. The axial direct damping coefficient and direct damping coefficients in two angular directions decrease with increasing squeeze number and supplying gas pressure. The axial direct damping coefficient decreases fast when the squeeze number is less than 20. The cross coupled dynamic stiffness and damping coefficients of two angular directions have an axisymmetric feature. The coupled dynamic stiffness and damping coefficients have a little relation with squeeze number when the number is in the range of 1-40, but increase with the increasing number if the number is larger than 40.
许恒杰, 宋鹏云. 三自由度微扰下的静压干气密封动态特性分析[J]. 排灌机械工程学报, 2017, 35(1): 56-64.
XU Hengjie, SONG Pengyun. Analysis on dynamic characteristics of aerostatic dry gas seals with three degrees of freedom perturbation. Journal of Drainage and Irrigation Machinery Engin, 2017, 35(1): 56-64.
[1]CHENG H S, CHOW C Y, WILCOCK D F. Behavior of hydrostatic and hydrodynamic non-contacting face seals[J]. Journal of tribology, 1967, 90(2):510-519.[2]KOGA,TASASHI,FUJITA,et al.High stiffness seal and its application to extreme condition[C]//Proc 10th Ind. Conf. on Fluid Sealing,Paper Ⅱ,1984.[3]YAMAMOTO M, MORI H, MIKI R,et al. Dynamic characteristics of Hydrostatic noncontact gas face seals [J]. Journal of Japan society of lubrication engineering, 1984, 29(6): 451-457.[4]STOLARSKI T A, XUE Y. Performance study of a back-depression mechanical dry gas seal[J]. Journal of engineering tribology,1998, 212(4):279-290.[5]FUJIWARA S,FUSE T.Advanced aerostatic dry gas seal[C]//Proceedings of the 16th International Conference on Fluid sealing,BHR Group 2000 Fluid Sealing,2000:483-499.[6]余建平. 静压气体润滑机械密封特性研究[D]. 昆明: 昆明理工大学, 2008.[7]王和顺,董霖,黄泽沛,等. 静压干气密封端面流场数值模拟[J]. 排灌机械工程学报, 2011, 29(2): 165-169. WANG Heshun, DONG Lin, HUANG Zepei, et al. Numerical simulation on flow flied of aerostatic dry gas seal [J]. Journal of drainage and irrigation machinery engineering, 2011, 29(2): 165-169.(in Chinese)[8]宋鹏云, 许恒杰. 静压气体润滑机械密封刚度特性的解析法分析[J].排灌机械工程学报, 2013, 31(12): 1077-1082. SONG Pengyun, XU Hengjie. Analytical analysis of stiffness characteristics of aerostatic dry gas seal [J]. Journal of drainage and irrigation machinery engineering, 2013, 31(12): 1077-1082.(in Chinese)[9]许恒杰,宋鹏云, 余建平.静压气体润滑机械密封性能分析[J]. 润滑与密封, 2013, 38(8): 41-45. XU Hengjie, SONG Pengyun, YU Jianping. Analysis on the seal performance of aerostatic dry gas seal [J]. Lubrication engineering, 2013, 38(8): 41-45.(in Chinese)[10]郑继科. 静压干气密封的动态特性及热变形研究[D].成都: 西华大学,2013.[11]马纲,何军,栗秀花,等. 柱面气膜密封动力特性系数的数值计算[J].机械工程学报,2013,49(5):55-62. MA Gang, HE Jun, LI Xiuhua, et al. Numerical calculation of dynamic coefficients for gas film cylinder seal[J]. Chinese journal of mechanical engineering, 2013,49(5):55-62.(in Chinese)[12]刘雨川. 端面气膜密封特性研究[D]. 北京: 北京航天航空大学, 2000.[13]刘雨川,徐万孚,王之栎,等. 端面气膜密封动力特性系数的计算[J]. 清华大学学报(自然科学版),2002, 42(2): 185-189. LIU Yuchuan, XU Wanfu, WANG Zhili, et al. Dynamic coefficients for gas film face seal [J]. Journal of Tsinghua University(science and technology), 2002, 42(2): 185-189.(in Chinese)[14]MILLER B A, GREEN I. Semi-analytical dynamic analysis of spiral-groove mechanical gas face seals [J]. Journal of tribology, 2003, 125(2):403-413.[15]RUAN B. A semi-Analytical solution to the dynamic tracking of non-contacting gas face seals [J]. Journal of tribology, 2002, 124(1): 196-202.[16]黄平, 许兰贵, 孟永钢, 等.求解磁头/磁盘超薄气膜润滑性能的有效有限差分算法[J]. 机械工程学报, 2007, 43(3): 43-49. HUANG Ping, XU Langui, MENG Yonggang, et al. Effective finite difference method to calculate lubricating performances of ultra-thin gas film of magnetic head/disk[J]. Chinese journal of mechanical engineering, 2007, 43(3): 43-49.(in Chinese)[17]姜培林,虞烈. 流体动压润滑推力轴承动特性的研究[J]. 西安交通大学学报, 1996, 30(6): 67-74. JIANG Peilin, YU Lie. Investigation on the dynamic characteristics of a hydrodynamic thrust bearing [J]. Journal of Xi'an Jiaotong University, 1996, 30(6): 67-74.(in Chinese)
