Abstract:In order to improve the poor separation performance of a conical hydrocyclone during the startup time of a pump unit,taking the DN50 type hydrocyclone as a model,the experimental investigations into the effects of the pump startup time on the separation performance were carried out using the working liquids with three sand mass fractions by means of the frequency variable control technology.The startup times 5,15,30,90 and 120 s for the liquids with 0.451% sand mass fraction,15,30,60 and 90 s for those with 0.266% and 0.124% fractions were applied,respectively.The experimental results showed that the shorter the start up time,the poorer the separation performance for larger size particles; while the longer the start up time,the poorer the performance for smaller size particles.During the start up period,both the total separation efficiency and the classification performance of hydrocyclone are deteriorated initially,and then get better,eventually reach constant levels.At a certain time instance of the same startup time,the classification performance presents a regular wavy variation with increasing size of particles.The particles larger than 0.2 mm in size achieve the best classification performance.It is recommended that the optimal start up time is 30 s when the pump works with the hydrocyclone at the flow rate of 15 m /h.
刘竹青, 郭聪, 严海军. 水泵启动时间对灌溉水力旋流器性能的影响[J]. 排灌机械工程学报, 2011, 29(6): 492-496.
LIU Zhu-Qing, GUO Cong, YAN Hai-Jun. Influence of pump start up time on performance of hydrocyclone used in irrigation system. Journal of Drainage and Irrigation Machinery Engin, 2011, 29(6): 492-496.
[1]Wang Zhibin,Chu Liangyin,Chen Wenmei,et al.Experimental investigation of the motion trajectory of solid particles inside the hydrocyclone by a Lagrange method[J].Chemical Engineering Journal,2008,138(1/2/3):19. [2]刘永平,龚 俊,刘 晶.黄河水泥沙分离用水力旋流器的溢流颗粒中位径分析[J].排灌机械,2007,25(3):34-37.Liu Yongping,Gong Jun,Liu Jing.Investigation of the particle median diameter of dydrocyclone for separation of sediments from Yellow River′s water[J].Drainage and Irrigation Machinery,2007,25(3):34-37.(in Chinese) [3]邱元锋,董文楚,罗金耀.微灌用水力旋流器试验研究[J].灌溉排水学报,2008,27(5):18-21.Qiu Yuanfeng,Dong Wenchu,Luo Jinyao.Experimental study on the new hydrocyclone separator for microirrigation[J].Journal of Irrigation and Drainage,2008,27(5):18-21.(in Chinese) [4]刘永平,龚 俊,刘 晶.黄河水泥沙分离用水力旋流器分离效率的研究[J].排灌机械,2006,24(5):33-35.Liu Yongping,Gong Jun,Liu Jing.Investigation of separation efficiency of hydrocyclone for separation of sediments from Yellow River′s water[J].Drainage and Irrigation Machinery,2006,24(5):33-35.(in Chinese) [5]辛 舟.基于滴灌的黄河水泥沙分离试验研究[J].排灌机械,2005,23(3):32-34.Xin Zhou.Silt of Yellow River separating based on drip irrigation[J].Drainage and Irrigation Machinery,2005,23(3):32-34.(in Chinese) [6]Saengchan K,Nopharatana A,Songkasiri W.Enhancement of tapioca starch separation with a hydrocyclone:Effects of apex diameter,feed concentration,and pressure drop on tapioca starch separation with a hydrocyclone[J].Chemical Engineering and Processing:Process Intensification,2009,48(1):195-202. [7]Puprasert C,Hebrard G,Lopez L,et al.Potential of using hydrocyclone and hydrocyclone equipped with grit pot as a pretreatment in run off water treatment[J].Chemical Engineering and Processing,2004,43(1):67-83. [8]林亚玲,李树君,李里特,等.水力旋流器分离马铃薯淀粉的试验研究[J].农业机械学报,2002,33(4):55-58.Lin Yaling,Li Shujun,Li Lite,et al.Experimental investigation on hydrocyclone for potato starch separation[J].Transactions of the Chinese Society for Agricultural Machinery,2002,33(4):55-58.(in Chinese) [9]王 军,刘焕芳,成玉彪,等.国内微灌用过滤器的研究与发展现状综述[J].节水灌溉,2003(5):34-35.Wang Jun,Liu Huanfang,Cheng Yubiao,et al.General introduction on research and development of domestic micoirrigation filters[J].Water Saving Irrigation,2003(5):34-35.(in Chinese) [10]韩丙芳,田军仓.微灌用高含沙水处理技术研究综述[J].宁夏农学院学报,2001,22(2):63-69.Han Bingfang,Tian Juncang.General introduction on the technology of purifying water for microirrigation with highsilt content water[J].Journal of Ningxia Agricultural College,2001,22(2):63-69.(in Chinese) [11]He Wuquan,Cai Mingke,Wang Yubao,et al.Automatic water supply control system of graded constant pressure by variable frequency speed and its application to pipeline irrigation[C]∥Proceedings of the 2nd WRI Global Congress on Intelligent Systems,2010:385-388. [12]褚良银,陈文梅,戴光清,等.水力旋流器[M].北京:化学工业出版社,1998:62-65.