Effects of pump hydraulic structure on vibration characteristics of series-parallel centrifugal pump
Li Yue1, Shi Weidong1, Han Xiaoxiao2
1.National Research Center of Pumps, Jiangsu University, Zhenjiang, Jiangsu 212013, China; 2.Research Institute of Chemical Machinery, Hefei University of Technology, Hefei, Anhui 230009, China
Abstract:In order to study the changes in performance and vibration characteristics for different structures in a series-parallel centrifugal pump, the original volute of a series-parallel centrifugal pump is replaced with a new structure-radial diffuser plus annular ring. The hydraulic design of the two structures is conducted by making use of existing hydraulic models and velocity constants method. An experimental stand is built according to relevant standards, then the performance and vibration characteristics of the pumps with two structures are measured on the stand, respectively. The vibration is monitored in the pump feet and analyzed in 1/3 octave band of vibration acceleration. The results show that the original volute configuration can achieve a higher pump efficiency but is subject to a high vibration level than the new structure. In particular, the noise level of the pump with the new structure is 3dB-4dB lower than the pump with the original volute structure. Unfortunately, the vibration characteristics at various monitoring points don′t show any regular patterns at each octave, and the noise changes from one monitoring point to another. As a result, when monitored parameters are assessed, all monitoring points should be taken into consideration in a comprehensive manner.
李跃, 施卫东, 韩笑笑. 不同结构形式对串并联离心泵振动特性的影响[J]. 排灌机械工程学报, 2015, 33(9): 744-749.
Li Yue, Shi Weidong, Han Xiaoxiao. Effects of pump hydraulic structure on vibration characteristics of series-parallel centrifugal pump. Journal of Drainage and Irrigation Machinery Engin, 2015, 33(9): 744-749.
[1]付强,朱荣生,李维斌.扭曲叶片离心泵叶轮内三维湍流数值模拟[J].排灌机械工程学报,2011,29(3):14-16. Fu Qiang,Zhu Rongsheng,Li Weibin. Numerical simulation of 3D turbulent flow in the centrifugal pump with twisted-blade[J]. Journal of Drainage and Irrigation Machinery Engineering,2011,29(3):14-16.(in Chinese)[2]马士虎,余栋高,谢江辉,等.新型串并联双级离心泵研制[J]. 船舶工程, 2002,3(6):38-41. Ma Shihu,Yu Donggao,Xie Jianghui,et al. Development of a new-type serial-parallel two-stage centrifugal pump [J].Journal of Ship Engineering,2002,3(6):38-41.(in Chinese)[3]于萍,孙卫平,杨志军.船用潜水式串并联离心泵的设计与研究[J]. 机电设备,2002(4):1-6. Yu Ping, Sun Weiping, Yang Zhijun. Design and research of marine submersible series multiple centrifugal pump[J]. Journal of Mechanical and Electrical Equipment,2002(4):1-6.(in Chinese)[4]关醒凡.现代泵理论与设计[M].北京:中国宇航出版社,2011:314-424.[5]Pedersen N,Larsen P S,Jacobsen C B. Flow in a centri-fugal pump impeller at design and off-design conditions—Part I: Particle image velocimetry(PIV)and laser Doppler velocimetry(LDV)measurements[J]. Journal of Fluids Engineering,2003, 125(1): 61-72.[6]孔繁余,王婷, 张洪利.基于流场数值模拟的多级泵转子动力学分析[J].江苏大学学报:自然科学版,2011,32(5):516-521. Kong Fanyu,Wang Ting,Zhang Hongli. Rotor dynamic analysis of multistage pump based on numerical simulation of flow field[J]. Journal of Jiangsu University:Na-tural Science Edition,2011,32(5):516-521.(in Chinese)[7]施卫东,李辉,陆伟刚,等.进口预旋对低比速离心泵无过载性能的影响[J].农业机械学报,2013,44(5):50-54. Shi Weidong,Li Hui,Lu Weigang,et al. Effect of pre-whirl flow on non-overload performance of low-specific-speed centrifugal pumps[J].Transactions of the Chinese Society for Agricultural Machinery,2013,44(5):50-54.(in Chinese)[8]Ngahara T,Inoue Y,Sato T,et al. Investigation of the flow field in a multistage pump by using LES[C]//Proceedings of the 2005 ASME Fluids Engineering Division Summer Meeting,2005: 1321-1329.[9]李靖,王晓放,周方明.非均布导叶对核主泵模型泵性能及压力脉动的影响[J].流体机械,2014,42(9):19-24. Li Jing,Wang Xiaofang,Zhou Fangming. Influence of uneven guide blade on performance and pressure fluctuation of nuclear model pump[J]. Fluid Machinery, 2014,42(9):19-24.(in Chinese)[10]Wernet M P. Development of digital particle imaging velocimetry for use in turbomachinery [J]. Experiments in Fluids, 2000, 28(2): 97-115.[11]Addie G R. Slurry pipeline design for operation with centrifugal pumps[C]//Proceedings of the International Pump Users′ Symposium, 1996: 193-212.[12]袁寿其.低比转速离心泵理论与设计[M]. 北京:机械工业出版社,1997:467.[13]王孚懋,王建春.噪声测量中1/3倍频程与倍频程频谱的关系与计算[J].噪声与振动控制,1996,5(3):39-41. Wang Fumao,Wang Jianchun. Noise measurement and calculation of the relationship between one-third octave and octave spectrum [J]. Noise and Vibration Control,1996,5(3):39-41.(in Chinese)[14]赵良省.噪声与振动控制技术[M]. 北京:化学工业出版社,1983.[15]王勇,刘庆,刘东喜,等.不同叶片冲角离心泵内流诱导振动噪声研究[J].流体机械,2013,41(7):1-4,32. Wang Yong,Liu Qing,Liu Dongxi,et al. Analysis of flow induced vibration and noise in centrifugal pumps with different blade inlet incidence angle[J]. Fluid Machi-nery, 2013,41(7):1-4,32.(in Chinese)