|
|
PIV experimental study on unsteady internal flow field in low-specific-speed sewage pump |
Wang Zhen1, Chen Bin2, Zhang Hua3, Hu Qixiang3, Gao Biao2 |
1.Nanjing Lanshen Pump Co. Ltd., Nanjing, Jiangsu 211500, China; 2.Research Institute of Chemical Machinery, Hefei University of Technology, Hefei, Anhui 230009, China; 3.National Research Center of Pumps, Jiangsu University, Zhenjiang, Jiangsu 212013, China |
|
|
Abstract Through modifying the structure of a traditional electromechanical integrated sewage pump, the test pump sector suitable for PIV measurement was obtained with plexiglas as impeller and volute material and with half-spiral suction chamber for changing flow direction. To shoot the flow field on the middle section of impeller at five different relative positions of impeller and volute under three different conditions, synchronous device as shaft encoder was adopted with hollow glassy microspheres acting as tracer particle, and fine results were finally achieved.From PIV measurement results, the internal flow field shows good axisymmetrical distributions at any time under conditions of 1.4Qd and 1.0Qd, while at extremely small flow rate 0.2Qd, the internal flow field becomes disordered and presents obvious non-axisymmetry. For passage A at five shooting moments, as it passes through the location of volute tongue, the relative velocity distribution gradient on outlet circumference as well as the strength and dimension of vortex at small flow rate are all subject to the intense interference of tongue. As for passage C, at extremely small flow rate, flow separation near pressure surface is intensifying to form vortex blocking most of the passage.
|
Received: 20 March 2014
|
|
|
|
[1]Huang B, Young Y L, Wang G, et al. Combined expe-rimental and computational investigation of unsteady structure of sheet/cloud cavitation[J]. Journal of Fluids Engineering, 2013,135(7):1-16.[2]Yang M G, Liu D, Yang B, et al. Research of the PIV technology used to measure the liquid-solid two-phase flow in the pump[J]. Proceedings of AIP Conference, 2007:425-429.[3]丛小青,袁寿其,袁丹青. 无过载排污泵正交试验研究 [J].农业机械学报,2005, 36(10):66-69. Cong Xiaoqing, Yuan Shouqi, Yuan Danqing.Research of latin square test on non-overload sewage pumps[J]. Transactions of the Chinese Society for Agricultural Machinery, 2005, 36(10):66-69.(in Chinese)[4]施卫东,蒋婷,曹卫东,等.高扬程无过载潜水排污泵的优化设计与试验[J]. 农业工程学报,2011,27(5):151-155. Shi Weidong, Jiang Ting, Cao Weidong, et al. Optimal design and experiment on a high-head non-overload submersible sewage pump[J].Transactions of the CSAE,2011, 27(5):151-155.(in Chinese)[5]Zhang Hua, Chen Bin, Shi Weidong, et al. Effects of contraction-type impeller on non-overloaded performance for low-specific-speed sewage pump[J]. Journal of Mechanical Science and Technology, 2014, 28(3):937-944.[6]陈斌, 施卫东, 张华, 等. 超厚叶片离心泵叶轮与蜗壳之间性能匹配的研究[J]. 水泵技术, 2012(6): 26-29. Chen Bin, Shi Weidong, Zhang Hua, et al. Research matching properties of centrifugal impeller with thick blade and volute[J]. Journal of Pump Technology, 2012(6): 26-29.(in Chinese)[7]Wang Kai, Liu Houlin, Yuan Shouqi, et al. Numerical simulation and stereo PIV test of inner flow in a double blades pump[C]//Proceedings of the 2011 ASME-JSME-KSME Joint Fluids Engineering Conference, 2011:1-9.[8]Kadambi J R,Charoenngam P,Subramanian A.Investigations of particle velocities in a slurry pump using PIV—Part Ι: The tongue and adjacent channel flow[J].Journal of Energy Resources Technology,2004,126(4):271-278.[9]Westra R W, Broersma L, Van Andel, et al. PIV measurements and CFD computations of secondary flow in a centrifugal pump impeller[J]. Journal of Fluids Engineering, 2010,132(6):0611041-0611048.[10]陈斌,张华,施卫东,等.低比转数潜水排污泵的内部流场PIV试验研究[J].排灌机械工程学报,2013,31(7): 575-579. Chen Bin, Zhang Hua, Shi Weidong, et al. PIV experimental study on flow field in submersible sewage pump with low specific speed[J].Journal of Drainage and Irrigation Machinery Engineering, 2013,31(7): 575-579.(in Chinese) |
|
|
|