|
|
|
| Numerical analysis of radial force in double-suction centrifugal pumps |
| Zhao Wanyong,Zhang Liang,Luo Jun |
| (College of Fluid Power and Control,Lanzhou University of Technology,Lanzhou,Gansu 730050,China) |
|
|
|
|
Abstract Numerical calculation of the internal flow field in a double suction centrifugal pump was performed by commercial CFD software.The static pressures along circumferential and axial directions on impeller-volute coupling surface were calculated.By comparing the experimental results with numerical calculations,good agreement was obtained,the relative error is less than 5%,and the tendency of pressure distribution for impeller exit from numerical calculation is consistent with the experimental one.The radial force and its components were calculated with the outlet pressure method.The results show that the application of numerical model to calculate the radial force of the centrifugal pump has certain accuracy.At small flow condition,the radial force decreases with the increase of flow rate;near the designed flow rate condition,the radial force reaches the minimum;and at large flow condition,the radial force increases with the flow rate.
|
|
Received: 24 May 2009
Published: 30 July 2009
|
|
|
|
| [1]赵万勇.大型离心泵的结构与运行[J].中国给水排水,2001,17(7):58-61.Zhao Wanyong.The structure and operation of large-scale centrifugal pump[J].China Water and Wastewater,2001,17(7):58-61.(in Chinese)[2]赵万勇.离心泵结构对大中型电动机窜轴的影响[J].排灌机械,2001,20(1):23-26.Zhao Wanyong.Influence of centrifugal pump configuration on axial travelling of shaft in large-and middle-sized driving motor[J].Drainage and Irrigation Machinery,2001,20(1):23-26.(in Chinese)[3]黄思,王国玉.离心泵内流场非对称性及受力的三维数值分析[J].农业机械学报,2006,37(10):66-69.Huang Si,Wang guoyu.Analysis of flow field asymmetry and force on centrifugal pump by 3-D numerical simulation[J].Transactions of the Chinese Society for Agricultural Machinery,2006,37(10):66-69.(in Chinese)[4]张亮.大型双吸离心泵径向力数值计算[D].兰州:兰州理工大学流体动力与控制学院,2009.[5]Iversen H W,Rolling R E,Carlson J J.Volute pressure distribution,radial force on the impeller,and volute mixing losses of a radial flow centrifugal pump[J].Journal of Engineering for Power,Transactions of the ASME,1960,82(2):136-144.[6]何东升,武学尧,张仲良,等.改型环形灌注泵的径向力研究[J].西安石油学院学报:自然科学版,2002,17(3):50-54.He Dongsheng,Wu Xueyao,Zhang Zhongliang,et al.Study on radial force of a modified centrifugal charging pump[J].Journal of Xi′an Petroleum Institute:Natural science edition,2002,17(3):50-54.(in Chinese)[7]王福军.计算流体动力学分析--CFD软件原理与应用[M].北京:清华大学出版社,2004.[8]Stepanoff A J.离心泵与轴流泵理论、设计和应用[M].北京:机械工业出版社,1980. |
|
|
|
