|
|
|
| Pressure fluctuation near double volute tongue for double-suction centrifugal pump |
| WANG Jiabin1, CHEN Jia2, YUAN Shouqi2, PEI Ji2, MENG Fan1 |
| 1.Shanddong Shuanglun Co. Ltd., Wweihai, Shandong 520000, China; 2.National Research Center of Pumps, Jiangsu University, Zhenjiang, Jiangsu 212013, China |
|
|
|
|
Abstract To study the pressure fluctuation near double volute tongue of a large flow rate double-suction centrifugal pump, the three-dimensional unsteady turbulent flow was numerically simulated with CFD software under different operational conditions. The characteristics of flow field and pressure fluctuation of the monitoring points near volute tongue were obtained, and pressure fluctuation intensity as well as the time and frequency spectra was analyzed respectively. The results show that high-pressure fluctuation intensity areas are mainly located between impeller outlet and volute tongue, which shows that the interaction of impeller and tongue will cause strong pressure fluctuation near volute tongue. Fluctuation intensity under 1.0Qd flow rate near both volute tongues is lower than that under large and small flow rates, and the distribution of pressure fluctuation intensity near A tongue becomes uniform gradually with the increasing of flow rate. Under 1.0Qd flow rate examined, in A tongue width direction, the double rotating frequency dominates the pressure fluctuation on middle position while other two sides are only one blade passing frequency; the dominant frequency on middle position and one side in B tongue width direction is double blade passing frequency while the other side is only one blade passing frequency. Under 1.0 Qd and 1.2Qd flow rate, the dominant frequency is double blade passing frequency at point P0 on middle position in A tongue width direction while it is only one blade passing frequency under 0.8Qd,and unapparent change of amplitude can be found for any flow rates in A tongue width direction, however, the pressure fluctuation amplitude on the same position near B tongue increases significantly under the conditions of 0.8Qd and 1.2Qd flow rate.
|
|
Received: 16 June 2015
|
|
|
|
| [1]蒋敦军,刘玉莹. 半螺旋形吸水室对离心泵压力脉动特性的影响[J]. 中国农村水利水电,2014(3):134-137. JIANG Duojun, LIU Yuying. The effect of half-spiral suction chamber on pressure fluctuation in centrifugal pump[J]. China rural water and hydropower, 2014(3):134-137.(in Chinese)[2]司乔瑞,袁寿其,袁建平,等. 基CFD/CA 的离心泵流动诱导噪声数值预测[J]. 机械工程学报,2013,49(22):177-184. SI Qiaorui, YUAN Shouqi, YUAN Jianping, et al. Flow-induced noise calculation of centrifugal pumps based on CFD/CA method[J].Journal of mechanical enginee-ring, 2013,49(22):177-184.(in Chinese)[3]OZTURK A,AYDIN K, SABIN B,et al. Effect of impeller-diffuser radial gap ratio in a centrifugal pump[J]. Journal of scientific and industrial research,2009,68(3):203-213.[4]FENG J,BENRA F K,DOHMEN H K. Unsteady flow visualization at part-load conditions of a radial diffuser pump: by PIV and CFD[J]. Journal of visualization,2009,12(1):65-72.[5]SUN H,XIAO R,LIU W,et al. Analysis of characteristics and pressure pulsations in a pump-turbine with misaligned guide vanes[J]. Journal of fluids engineering,2013,135(5): 051101.[6]江伟,李国君,张新盛. 离心泵叶片出口边倾斜角对压力脉动的影响[J]. 排灌机械工程学报,2013,31(5):369-372. JIANG Wei,LI Guojun,ZHANG Xinsheng. Effect of oblique angle of blade trailing edge on pressure fluctuation in centrifugal pump[J]. Journal of drainage and irrigation machinery engineering, 2013,31(5):369-372.(in Chinese)[7]RAN H,LUO X,ZHU L,et al. Experimental study of the pressure fluctuations in a pump turbine at large partial flow conditions[J]. Chinese journal of mechanical engineering,2012,25(6):1205-1209.[8]施瀚昱,牟介刚,郑水华等. 双蜗壳泵隔板长度对径向力平衡的影响[J]. 浙江农业学报,2013,25(6):1378-1382. SHI Hanyu, MU Jiegang, ZHENG Shuihua,et al. Effect of different baffle length of double volute pump on radial force pump[J].Acta agriculturae Zhejiangensis, 2013, 25(6): 1378-1382.(in Chinese)[9]蒋跃,李红,刘宜. 单、双出口双蜗壳泵的压力脉动及径向力特性[J]. 排灌机械工程学报,2014,32(9):748-753. JIANG Yue, LI Hong, LIU Yi. Pressure fluctuation near volute tongue and analysis of radial force characte-ristics of single and double volute pump[J]. Journal of drainage and irrigation machinery engineering, 2014,32(9):748-753.(in Chinese)[10]肖若富,吕腾飞,王福军. 双蜗壳式双吸泵隔板结构对叶轮径向力的影响[J]. 农业机械学报,2011,42(9):85-88. XIAO Ruofu, LYU Tengfei, WANG Fujun. Influence of rib structure in double-volute centrifugal pumps on the impeller radial force[J]. Transactions of the CSAM, 2011,42(9): 85-88.(in Chinese)[11]BENRA F K, DOHMEN H J. Numerical and experimental investigation of the flow in a centrifugal pump stage[C]//Proceedings of the 5th WSEAS International Conference on Fluid Mechanics. Acapulco, Mexico:[s.n.], 2008.[12]KHALIFA A E, ALQUTUB A M, BENMANSOUR R. Study of pressure fluctuations and induced vibration at blade-passing frequencies of a double volute pump[J]. Arabian journal for science and engineering, 2011, 36(7):1333-1345.[13]ZHOU P J, WANG F J, YANG M. Internal flow nume-rical simulation of double-suction centrifugal pump using DES model[C]//Proceedings of the 26th IAHR Symposium on Hydraulic Machinery and Systems—IOP Conference Series: Earth and Environmental Science, 2012: 032051.[14]姚志峰,王福军,肖若富,等. 双吸离心泵吸水室和压水室压力脉动特性试验研究[J]. 水利学报,2012,43(4):473-479. YAO Zhifeng, WANG Fujun, Xiao Ruofu,et al. Experimental investigation on pressure fluctuations in suction chamber and volute of a double-suction centrifugal pump[J]. Journal of hydraulic engineering, 2012, 43(4): 473-479.(in Chinese)[15]司乔瑞,袁寿其,袁建平,等.叶片与隔舌干涉对离心泵性能和压力脉动影响的数值研究[J].流体机械,2012,40(8):22-26. SI Qiaorui, YUAN Shouqi, YUAN Jianping, et al. Effect of interaction between blade and volute tongue of centrifugal pumps on the performance and pressure pulsation[J]. Fluid machinery,2012,40(8):22-26.(in Chinese)[16]刘国辉,闫晓伟. 双吸泵的多相位定常三维数值模拟[J]. 船电技术,2013,33(1): 11-14,17. LIU Guohui, YAN Xiaowei. 3D numerical simulation of double-suction pump with steady multi-phase position [J].Marine electric & electronic technology, 2013, 33(1): 11-14,17.(in Chinese)[17]杨敏,闵思明,王福军.双蜗壳泵压力脉动特性及叶轮径向力数值模拟[J].农业机械学报,2009,40(11):83-88. YANG Min, MIN Siming, WANG Fujun. Numerical simulation of pressure fluctuation and radial force in a double volute pump[J]. Transactions of the CSAM, 2009, 40(11): 83-88.(in Chinese)[18]裴吉,袁寿其,袁建平,等. 单叶片离心泵压力脉动强度多工况对比研究[J]. 华中科技大学学报(自然科学版), 2013, 41(12): 29-33,53. PEI Ji, YUAN Shouqi, YUAN Jianping, et al. Comparative study of pressure fluctuation intensity for a single blade pump under multiple operating conditions[J]. Journal of Huazhong University of Science & Technology(natural science edition), 2013, 41(12):29-33,53.(in Chinese)[19]PEI Ji,YUAN Shouqi,BENRA F K,et al. Numerical prediction of unsteady pressure field within the whole flow passage of a radial single-blade pump[J]. Journal of fluids engineering,2012,134(10):101103. |
|
|
|
