排灌机械工程学报
   Home  About Journal  Editorial Board  Author Center  Subscriptions    中文 
Journal of Drainage and Irrigation Machinery Engin  2014, Vol. 32 Issue (3): 196-201    DOI: 10.3969/j.issn.1674-8530.13.0152
article Current Issue | Next Issue | Archive | Adv Search Previous Articles  |  Next Articles  
Characteristics of pressure pulsation in multi-stage submersible pump
Shi Weidong1, Xu Yan1, Zhang Qihua1, Wang Guotao2, Lu Weigang1, Ma Dongqi3
1.National Research Center of Pumps, Jiangsu University, Zhenjiang, Jiangsu 212013, China; 2.Jiangsu Province Special Equipment Safety Supervision Inspection Institute Changzhou Branch, Changzhou, Jiangsu 213016, China; 3.Fujian Academy of Mechanical Sciences, Fuzhou, Fujian 350005, China
 Download: PDF (1588 KB)   HTML (1 KB)   Export: BibTeX | EndNote (RIS)      Supporting Info
Abstract In order to investigate the transient operation characteristics of multi-stage submersible pumps, three-dimensional, unsteady numerical simulations were conducted by using the standard k-ε turbulence model, SIMPLEC algorithm based on the sliding mesh technique in Fluent. The perfor-mance of the pump was obtained and compared with the experimental results. Besides, the pressure pulsations at various monitoring points were acquired; subsequently they were analyzed in time and frequency domains, respectively. It was demonstrated that the pressure fluctuation at all the monitoring points changes periodically with time, its number of periods is identical to the number of blades but less affected by the number of guide vane blades, its frequency is close to the blade passing frequency. The frequency of pressure fluctuation within the impeller increases gradually towards the impeller outlet and approaches the maximum value there, while the variation tendency of the frequency is opposite within the guide vane. The mostly dramatic pressure fluctuation occurs at the impeller outlet, the main frequency at various monitoring points is almost equal to the blade passing frequency. The amplitude of pressure pulsation coefficient at the monitoring points in the second stage impeller is higher than the first stage impeller. There still are two peaks in the pressure pulsation profiles in the second stage guide vane, suggesting pressure pulsation is not eliminated completely there. Additionally, the main frequency of pressure pulsation in the first stage guide vane is different from the second stage guide vane.
Service
E-mail this article
Add to my bookshelf
Add to citation manager
E-mail Alert
RSS
Articles by authors
SHI Wei-Dong-
XU Yan-
ZHANG Qi-Hua-
WANG Guo-Tao-
LU Wei-Gang-
MA Dong-Qi-
Key wordsmulti-stage submersible pump   pressure pulsation   rotor-stator interaction   numerical simulation   characteristic analysis     
Received: 2013-05-13;
Cite this article:   
SHI Wei-Dong-,XU Yan-,ZHANG Qi-Hua- et al. Characteristics of pressure pulsation in multi-stage submersible pump[J]. Journal of Drainage and Irrigation Machinery Engin, 2014, 32(3): 196-201.
 
[1] Perez R X, Akins R A, Lee C E, et al. Fiber-optic pressure sensors detect cavitation and flow instabilities in centrifugal pumps [J]. World Pumps, 1996(359):28-33.
[2] Zhang M, Tsukamoto H. Unsteady hydrodynamic forces due to rotor-stator interaction on a diffuser pump with identical number of vanes on the impeller and diffuser [J]. Journal of Fluids Engineering, 2005, 127(4):743-751.
[3] Rodriguze C G, Egusquiza E, Santos I F. Frequencies in the vibration induced by the rotor stator interaction in a centrifugal pump turbine [J]. Journal of Fluids Engineering, 2007,129(11):1428-1435.
[4] Feng J J, Benra F K, Dohmen H J. Investigation of periodically unsteady flow in a radial pump by CFD simulations and LDV measurements [J]. Journal of Turbomachinery, 2011, 133(1):011004.
[5] Lucius A, Brenner G. Numerical simulation and evaluation of velocity fluctuations during rotating stall of a centrifugal pump [J]. Journal of Fluids Engineering, 2011, 133(8):081102.
[6] 杨孙圣,孔繁余,张新鹏,等. 液力透平非定常压力脉动的数值计算与分析[J]. 农业工程学报,2012,28(7):67-72.
Yang Sunsheng, Kong Fanyu, Zhang Xinpeng, et al. Simulation and analysis of unsteady pressure fluctuation in hydraulic turbine [J]. Transactions of the CSAE, 2012, 28(7):67-72.(in Chinese)
[7] 张宁,杨敏官,李忠,等. 侧壁式压水室离心泵的压力脉动特性[J]. 机械工程学报, 2012, 48(14): 164-168.
Zhang Ning,Yang Minguan,Li Zhong,et al. Pressure pulsation of centrifugal pump with tilt volute [J]. Journal of Mechanical Engineering, 2012, 48(14): 164-168.(in Chinese)
[8] Feng J J, Friedrich-Karl B, Hans J D. A new method to simulate rotor-stator interactions in a centrifugal pump stage [C]//Proceedings of the 8th ESDA Biennial ASME Conference on Engineering Systems Design and Analysis. Torino, Italy:[s.n.],2006: 677-684.
[9] 王福军,张玲,张志民. 轴流泵不稳定流场的压力脉动特性研究[J]. 水利学报,2007,38(8): 1003-1009.
Wang Fujun, Zhang Ling, Zhang Zhimin. Analysis on pressure fluctuation of unsteady flow in axial-flow pumps [J]. Journal of Hydraulic Engineering, 2007, 38(8): 1003-1009.(in Chinese)
[10] Zhang D S, Shi W D, Chen B, et al. Unsteady flow analysis and experimental investigation of axial-flow pump[J]. Journal of Hydrodynamics:Ser B, 2010, 22(1):35-44.
[11] Zhang Desheng, Shi Weidong, Guan Xingfan, et al. Investigations of unsteady flow field characters in axial flow pump based on numerical simulation [C]//Proceedings of the ASME-JSME-KSME 2011 Joint Fluids Engineering Conference. Hamamatsu, Shizuoka, Japan:[s.n.],2011:97-105.
[12] 王春林,易同祥,吴志旺,等. 混流式核主泵非定常流场的压力脉动特性分析[J].动力工程,2009,29(11):1036-1040.
Wang Chunlin, Yi Tongxiang, Wu Zhiwang, et al. Analysis on pressure fluctuations of unsteady flow field in mixed-flow main coolant pump [J]. Journal of Power Engineering, 2009, 29(11): 1036-1040.(in Chinese)
[13] 施卫东,邹萍萍,张德胜,等. 高比转速斜流泵内部非定常压力脉动特性[J]. 农业工程学报,2011,27(4):147-152.
Shi Weidong, Zou Pingping, Zhang Desheng, et al. Unsteady flow pressure fluctuation of high-specific-speed mixed-flow pump [J]. Transactions of the CSAE, 2011, 27(4):147-152.(in Chinese)
[14] 尹俊连,刘锦涛,王乐勤,等. 水泵水轮机泵工况小流量区压力脉动预测[J]. 工程热物理学报, 2011, 32(7):1141-1144.
Yin Junlian, Liu Jintao, Wang Leqin, et al. Prediction of pressure fluctuations of pump turbine under off-design condition in pump mode [J]. Journal of Engineering Thermophysics, 2011, 32(7):1141-1144.(in Chinese)
[15] 周岭,施卫东,陆伟刚,等. 深井离心泵内部非定常流动的压力脉动特性分析[J]. 农业工程学报,2011,27(10):44-49.
Zhou Ling, Shi Weidong, Lu Weigang, et al. Analysis on pressure fluctuation of unsteady flow in deep-well centrifugal pump [J]. Transactions of the CSAE, 2011, 27(10):44-49.(in Chinese)
[1] Liu Dong, Zhu Jian, Wang Yingze, Yang Xiaoyong, Wang Chunlin. Numerical simulation of slit wall effect on Taylor-Couette flow stability[J]. Journal of Drainage and Irrigation Machinery Engin, 2014, 32(3): 242-246.
[2] Fu Yanxia,, Yuan Shouqi, Yuan Jianping, Fu Yuedeng, Huang Ping. Internal flow characteristics of centrifugal pump at low flow rates[J]. Journal of Drainage and Irrigation Machinery Engin, 2014, 32(3): 185-190.
[3] Liu Zhongzu, Wang Qiubo. Numerical analysis of flow field and pulsation characteristics in rotary lobe pump[J]. Journal of Drainage and Irrigation Machinery Engin, 2014, 32(3): 208-213.
[4] Wei Qingshun,, Sun Xihuan, Liu Zailun. Path analysis of effects of diffuser geometric parameters on performance of submersible pump[J]. Journal of Drainage and Irrigation Machinery Engin, 2014, 32(3): 202-207.
[5] Qian Zhongdong, Zhang Kai, Wang Zhiyuan, Xue Jun. Effect of blade leading edge shape on sediment erosion of blade in double-suction centrifugal pumps[J]. Journal of Drainage and Irrigation Machinery Engin, 2014, 32(2): 103-107.
[6] Quan Hui, Li Rennian, Su Qingmiao, Han Wei, Cheng Xiaorui, Shen Zhengjing. Energy conversion mechanism of screw centrifugal pump under single-phase[J]. Journal of Drainage and Irrigation Machinery Engin, 2014, 32(2): 130-135.
[7] Zhu Rongsheng,, Lin Peng, Long Yun, Wang Zhenwei, Xi Yi. Numerical simulation of solid-liquid two-phase flow in screw axial-flow pump[J]. Journal of Drainage and Irrigation Machinery Engin, 2014, 32(1): 6-11.
[8] Li Yanchao,, Li Mingzhong, Wang Weiyang, Wang Lei. Experiments and numerical simulations of gravel packed layer damage due to sand migration[J]. Journal of Drainage and Irrigation Machinery Engin, 2014, 32(1): 56-59.
[9] Yang Junhu, Li Hailong, Gong Zhaohui, Xia Shuqiang, Luo Kaikai. Radial thrust behavior in centrifugal pump as hydro-turbine[J]. Journal of Drainage and Irrigation Machinery Engin, 2014, 32(1): 12-16.
[10] Wang Xinkun, Xia Liping, Gao Shikai, Xu Peng. Numerical simulation of effects of piston key structural parameters on performance of jet fertilizer pump[J]. Journal of Drainage and Irrigation Machinery Engin, 2014, 32(1): 66-71.
[11] Jin Shuanbao, Wang Yongsheng. 3D design of axial-flow pump and numerical prediction of its cavitaion performance[J]. Journal of Drainage and Irrigation Machinery Engin, 2013, 31(9): 763-767.
[12] Wang Xinkun, Gao Shikai, Xia Liping, Xu Peng. Numerical simulation and structural optimization of screen filter in micro-irrigation[J]. Journal of Drainage and Irrigation Machinery Engin, 2013, 31(8): 719-723.
[13] Zhao Fei, Fu Jie, Song Wenwu, Wang Chunzhi. Structural design and performance research of seven-channel spherical check valve[J]. Journal of Drainage and Irrigation Machinery Engin, 2013, 31(8): 708-712.
[14] Liu Zailun,, Li Zhenhua, Wu Jiao, Zeng Jilai. Influence of increments of back sealing ring diameter of impeller on characteristic of axial force[J]. Journal of Drainage and Irrigation Machinery Engin, 2013, 31(8): 662-666.
[15] Li Yaojun, Shen Jinfeng, Hong Yiping, Tang Xuelin, Zhang Zhimin. Effect of tip clearance on unsteady flow in axial-flow pump[J]. Journal of Drainage and Irrigation Machinery Engin, 2013, 31(8): 667-673.

Copyright © 2011 Journal of Drainage and Irrigation Machinery Engineering
Support by Beijing Magtech Co.Ltd   E-mail: support@magtech.com.cn