[an error occurred while processing this directive]
排灌机械工程学报
   Home  About Journal  Editorial Board  Author Center  Subscriptions    中文 
Journal of Drainage and Irrigation Machinery Engin  0, Vol. Issue (): 6-    DOI:
article Current Issue | Next Issue | Archive | Adv Search Previous Articles  |  Next Articles  
Energy Saving Research And Application of Circulating Cooling Water Systems
 Download: PDF (0 KB)   HTML (1 KB)   Export: BibTeX | EndNote (RIS)      Supporting Info
Abstract  In order to improve the bad condition of circulating cooling water systems such as low efficiency and high energy waste due to incorrect pump selection, unreasonable working condition regulation, unscientific operating management and hard energy consumption evaluation. A chemical circulating water system was taken for object with the procedures as spot investigation on the parameters of equipment installation and the working conditions of the pump station, compared it with the working condition under variable frequency speed regulation and found out the energy saving potential then the energy consumption and evaluation of the whole system was finished. A water supply strategy on energy-saving operation of the circulating water system was established based on the pump affinity low and was combined with components and the whole system. The strategy can meet the process demand and implement the constant pressure water supply at the most adverse point. A method of energy consumption evaluation based on the pump performance curves, motor load curves and data collected was also summarized. After the chemical circulating water system was reconstructed, the annual electric power consumption was reduced from 2.1×104 kWh to 1.4×104kWh, the power-saving proportion was nearly 33% according to the result of energy consumption monitoring.
Service
E-mail this article
Add to my bookshelf
Add to citation manager
E-mail Alert
RSS
Articles by authors
Key wordscooling water systems   pump station   variable frequency operation   energy saving reconstruction;energy audit     
Cite this article:   
. Energy Saving Research And Application of Circulating Cooling Water Systems[J]. Journal of Drainage and Irrigation Machinery Engin, 0, (): 6-.
 
[1] 宋晓辉,王兴武等循环水系统的优化设计[J] 中国给水排水,2004 n12:67~69
[2] Song Xiaohui,Wang Xingwu,etc. Optimization Design of Circulating Water System [J] CHINAWATER & WASTEWATER,2004 n12:67~69 
[3] 丁学俊 冯慧雯等 循环水系统的经济运行问题的分析[J] 电站系统工程,1999:16~18
[4] Ding Xuejun,Feng Huiwen,etc.The analysis of economic operation of circulating systems [J]Power System Engineering,1999:16~18
[5] 干浙民. 恒压变流量供水系统中值得研讨的几个问题[J]. 排灌机械,1997(1):16~19
[6] Yu Zhemin,Some valuable questions of constant pressure and variable flow water supplysystems[ J ]. Drainage and Irrigation Machinery, 1997(1):16~19.
[7] Williams A A. The turbine performance of centrifugal pumps : a comparison ofprediction methods [ J ]. Proceedings of the Institution of Mechanical Engineer s, PartA: Journalof power and energy ( S0957 - 6509) , 1994,208 (1) : 59 - 66 .
[8] Pelli T,Hitz H U,Energy indicators and savings in water supply[J],AmericanWater Works Association,2000,92(6):55~62
[9] 任力,王光辉,花文胜等. 水泵现场测试技术探讨[J]. 供水技术,2008,2(3):34~36
Renli,Wang Guanghui,Hua Wensheng,etc.Discussion on the on-site testing of pumps [J]. WaterTechnology,2008,2(3):34~36
[10] 施卫东 ,张德胜 ,郎涛等.基于 LabV IEW的水泵性能测试系统的设计 [ J ].排灌机械 , 2007, 25 (3) : 38~41 .
Shi Weidong,Zhang Desheng,Lang Tao, etc. Development of pump performance test systembased on LabVIEW [ J ]. Drainage and Irrigation Machinery, 2007, 25 (3) : 38~41 . ( inChinese)
[11] 王新坤.轻小型喷灌机组能好计算与评价方法 [J]. 排灌机械,2010(3):247~250Wang Xinkun. Energy consumption calculation and evaluation methods for light and small unitsprinkler system [ J ]. Drainage and Irrigation Machinery, 2010 (3):247~250 . ( in Chinese)
[12] 刘超,泵站经济运行[M],北京:水利水电出版社,1995
[13] Liu Chao,Economic running of pump stations [M],Beijing:Hydraulic and Hydropowerpublishing house,1995
[14] Nourbakhsh A,Jaumotte A,Hirsch C,et al,Turbo pumps and Pumping SystemsM],New York:Spring Berlin Heidelberg,2007:17~30
[15] Walski T M,Realizing energy savings in water system operation[J],ASCE Conf,Water Resources Planning and Management,1989:441~444
[1] . Comparison of power generation scheme and benefit analysis for pump units in Jiangdu No.3 Pumping Station in reverse mode[J]. Journal of Drainage and Irrigation Machinery Engin, 2012, 30(3): 330-334.
[2] XU Cun-Dong, YANG Ke, XIAO Lu, SONG Yong-Zhan, HUANG Xiong. Simulation of vertical inlet pipes layout effect on pump inflow patterns[J]. Journal of Drainage and Irrigation Machinery Engin, 2012, 30(1): 40-45.
[3] ZHANG Ren-Tian, LI Ci-Xiang, YAO Lin-Bi, ZHU Hong-Geng. Startup transient behavior of bulb pump unit with VFD[J]. Journal of Drainage and Irrigation Machinery Engin, 2012, 30(1): 46-52.
[4] Qiu Jinxian1, Cheng Jilin1, Zhang Rentian2, Zhang Lihua1. Application of traditional decomposition amalgamation method based on DPSA in optimal regulation of parallel pumping stations[J]. Journal of Drainage and Irrigation Machinery Engin, 2011, 29(6): 497-502.
[5] Sheng Ping, Wang Yuxiu, Guo Yangyang, Wang Leiqiang. System design for monitoring of more sewage treatment plant based on ZigBee and 3G[J]. Journal of Drainage and Irrigation Machinery Engin, 2011, 29(6): 503-507.
[6] Tang Xuelin, Wang Wuchang, Wang Fujun, Li Yaojun. Numerical simulation of slitladen flows in pumping station forebay[J]. Journal of Drainage and Irrigation Machinery Engin, 2011, 29(5): 411-417.
[7] Feng Xiaoli, Qiu Baoyun, Yang Xingli, Shen Jian, Pei Bei.  Optimal methods and its application of large pumping station operation[J]. Journal of Drainage and Irrigation Machinery Engin, 2011, 29(2): 127-132.
[8] Gao Chuanchang, Wang Yuchuan, Shi Liwen, Liu Wei, Yang Hongcun. Technical measure for discontinuous trajectory bucket energy dissipation and sediment prevention at forebay of pumping station[J]. Journal of Drainage and Irrigation Machinery Engin, 2011, 29(2): 133-138.
[9] Zhang Lei, Wei Long, Feng Fei, Tu Zhongqiang, Xu Zhigao. Optimization and system development of circulating water pump in thermal power plant based on theory of energy value[J]. Journal of Drainage and Irrigation Machinery Engin, 2011, 29(2): 144-148.
[10] Liang Jindong, Lu Linguang, Liu Ronghua, Wang Gang. Influence of middle division pier on hydraulic performance in pumping station outlet conduit[J]. Journal of Drainage and Irrigation Machinery Engin, 2011, 29(1): 77-81.

Copyright © 2011 Journal of Drainage and Irrigation Machinery Engineering
Support by Beijing Magtech Co.Ltd   E-mail: support@magtech.com.cn