Design and experiment on driving power supply for drip irrigation piezoelectric pump
SUN Fuchun1, HU Caiqi1, LI Shengduo1, HU Xiaoqi2, LI Jie1, JI Jing1
1.College of Mechanical and Electrical Engineering, Qingdao Agricultural University, Qingdao, Shandong 266109, China; 2. College of Engineering and Design, Lishui University, Lishui, Zhejiang 323000, China
Abstract:According to the requirement on driving power supply by a drip irrigation piezoelectric pump, a switch driving power supply is designed in this paper based on the EG8010 inverter chip by adopting single phase bridge voltage inverter, rectifier circuit and SPWM control sine wave generator chip. Firstly, the structure and working principle of driving power supply are proposed for drip irrigation piezoelectric pumps. Secondly, a single phase sine wave with continuously adjustable excitation voltage and frequency is formed by using the corresponding control regulation circuit. Then the output voltage feedback and regulation circuits, frequency control circuit and temperature monitor circuit are designed with hardware. At last, an experiment is carried out based on the single phase sine wave which will be used as an excitation source of drip irrigation piezoelectric pump. The results show that this driving power supply has a few advantages, namely dead time control equipped, high stability, low waveform distortion, simple structure, small volume, convenient operation, low cost and etc. compared with the traditional driving power supply unit which is composed of a signal generator and a power amplifier, and it can meet the requirement on driving and control by a drip irrigation piezoelectric pump.
孙夫纯, 胡彩旗, 李胜多, 胡笑奇, 李杰, 纪晶. 滴灌压电泵的驱动电源设计与试验研究[J]. 排灌机械工程学报, 2016, 34(9): 761-766.
SUN Fuchun, HU Caiqi, LI Shengduo, HU Xiaoqi, LI Jie, JI Jing. Design and experiment on driving power supply for drip irrigation piezoelectric pump. Journal of Drainage and Irrigation Machinery Engin, 2016, 34(9): 761-766.
[1]武鹏. 灌水器抗堵塞及对滴灌系统灌水均匀度的影响[D]. 杨凌:中国科学院研究生院(教育部水土保持与生态环境研究中心), 2010.[2]杨胜敏,李贵兵. 再生水滴灌条件下灌水器抗堵塞试验研究[J]. 中国农村水利水电,2010(1): 6-7. YANG Shengmin, LI Guibing. Research on anti-clogging of emitters under drip irrigation with reclaimed water [J]. China rural water conservancy and hydropower. 2010(1): 6-7.(in Chinese)[3]陈龙,任皓,袁朝春,等. 轮毂电动机HEV动力系统设计与仿真[J].江苏大学学报(自然科学版),2015, 36(1): 6-11. CHEN Long, REN Hao, YUAN Chaochun, et al. Design and simulation power system for hybrid electric vehicles with wheel motors[J]. Journal of Jiangsu University(natural science edition), 2015, 36(1): 6-11.(in Chinese)[4]胡笑奇,方雅敏,张蕊华,等. 刚柔结构仿尾鳍压电双晶片无阀泵的实验研究[J]. 振动、测试与诊断, 2015, 35(3): 476-480. HU Xiaoqi, FANG Yamin, ZHANG Ruihua, et al. Experimental study of caudal-fin-like piezoelectric-bimorph valveless pump with flexible-rigid structure[J]. Journal of vibration, measurement & diagnosis, 2015, 35(3): 476-480.(in Chinese)[5]LENG X, ZHANG J, JIANG Y, et al. Theory and experimental verification of spiral flow tube-type valveless piezoelectric pump with gyroscopic effect[J]. Sensors and actuators a:physical, 2013, 195(6): 1-6.[6]谈明高,崔建保,刘厚林,等. 太阳能水泵系统的研究现状与趋势[J]. 流体机械,2013, 41(7):33-39. TAN Minggao,CUI Jianbao,LIU Houlin, et al. Research status and development trends of solar powered water pumps [J]. Fluid machinery, 2013, 41(7):33-39.(in Chinese)[7]KARPELSON M, WEI G, WOOD R J. Driving high voltage piezoelectric actuators in microrobotic applications[J]. Sensors and actuators a:physical,2012, 176(4): 78-89.[8]RIOS S A, FLEMING A J. A new electrical configuration for improving the range of piezoelectric bimorph benders [J]. Sensors and actuators a: physical, 2015, 224(1): 106-110.[9]GHOSH B, JAIN R K, ROY S S, et al. A method for controlling bimorph piezoelectric actuator using fuzzy logic controller towards robotic assembly[C]//Proceedings of the 2nd International and 17th National Conference on Machines and Mechanisms,India, Kanpur: 2015.[10]GABRIELE C, MASSIMO B, FRANCESCO R, et al. A realtime identification algorithm for active control of smart structures [C]//Proceedings of the 2014 IEEE Conference on Control Applications(CCA), 2014.[11]CUPIAŁ P. Three-dimensional perturbation solution of the natural vibrations of piezoelectric rectangular plates[J]. Journal of sound and vibration,2015, 351: 143-160.[12]胡笑奇,张建辉,黄毅. 仿尾鳍压电双晶片无阀泵的模拟与试验[J]. 振动、测试与诊断,2011, 31(2): 193-197. HU Xiaoqi, ZHANG Jianhui, HUANG Yi. Simulation and design of caudal-fin-type valveless pump driven by piezoelectric bimorphs [J]. Journal of vibration, measurement & diagnosis,2011, 31(2): 193-197.(in Chinese)[13]张建辉,胡笑奇,赵淳生. 仿鱼摆动式无阀压电泵的新进展[J]. 振动、测试与诊断,2016,36(1): 1-10. ZHANG Jianhui, HU Xiaoqi, ZHAO Chunsheng. New development of valve-less piezoelectric pump imitating caudal-fin[J]. Journal of vibration, measurement & diagnosis, 2016, 36(1): 1-10.(in Chinese)[14]胡笑奇,张建辉,黄毅,等. 仿尾鳍式变截面摆动振子无阀压电叠堆泵的结构设计[J]. 光学精密工程,2011, 19(6): 1334-1343. HU Xiaoqi, ZHANG Jianhui, HUANG Yi, et al. Structure design of caudal-fin-type piezoelectric-stack pump with variable cross-section oscillating vibrator[J]. Optics and precision engineering,2011, 19(6): 1334-1343.(in Chinese)[15]王强. 软开关PWM逆变器的研究及其在电气传动控制系统中的应用[D].沈阳: 东北大学, 2010.[16]张铁民,许志林,曹飞,等. 宏微压电驱动器的电源设计与试验[J]. 压电与声光, 2015, 37(1): 167-171. ZHANG Tieming, XU Zhilin, CAO Fei, et al.Design and experiment of a power supply to drive a macro-micro piezoelectric actuator[J]. Piezoelectrics & acoustooptics, 2015, 37(1): 167-171.(in Chinese)[17]张占松,蔡宣三. 开关电源的原理与设计[M]. 北京:电子工业出版社, 1998.