Abstract：In order to verify the function of greenhouse hot blast heating testsystem based on porous pipes, the heating process was studied with inlet temperature, inlet pressure and outlet diameter of porous pipes as testing factors. Through thermal insulating porous pipes, measuring the temperature rise in thermal insulated room, the hot blast heating process was tested and analyzed under different testing factors. Measured data was polynomial regressed so as to obtain the mathematic relation between the temperature rise in thermal insulated room and inlet temperature, inlet pressure of porous pipes. The test results indicate that the temperature in thermal insulated room rises about 4 degrees Celsius to 9 degrees Celsius, the relations between temperature rise and inlet temperature, inlet pressure of porous pipes are positive correlation, and the main influencing factor of the temperature rise is inlet pressure rather than inlet temperature. Under the set influencing factors according to mathematic relations determined by testing and analysis, the system is applicable for heating greenhouse in winter.
[1] 王新坤，李 红.我国温室的研究现状与发展趋势[J].排灌机械工程学报，2010,28（2）：179-184.Wang Xinkun,Li Hong. Current research status and development trend of greenhouse in China[J]. Journal of Drainage and Irrigation Machinery Engineering, 2010,28(2):179-184.（in Chinese）[2] 周长吉.现代温室工程［M］.北京:化学工业出版社,2003：138.[3] 迟宏伟,黎东光,刘忠华.热风炉用于寒冷地区棚室增温效果分析[J].农机化研究,1999,21(4):97-99.Chi Hongwei,Li Dongguang,Liu Zhonghua. Analysis of warming effect in cold regions greenhouse with hot blast stove[J].Journal of Agricultural Mechanization Research,1999，21(4):97-99.（in Chinese）[4] 曲 梅,马承伟,李树海,等.地面加热系统温室热环境测定与经济分析[J].农业工程学报,2003,19(1):180-183.Qu Mei,Ma Chengwei,Li Shuhai,et al.Analysis of thermal environment of greenhouse with floor heating system[J].Transactions of the CSAE,2003,19(1):180-183.（in Chinese）[5] 汪郑邦.现代温室供热系统的设计及运行模拟研究［D］.哈尔滨:哈尔滨工业大学市政环境工程学院,2006.[6] 盛军强.热风采暖条件下温室热环境数值分析与研究［D］.杭州:浙江工业大学机电工程学院,2007. [7] 陈教料,胥 芳,张立彬,等.基于CFD技术的玻璃温室加热环境数值模拟[J].农业机械学报,2008,39(8):114-118.Chen Jiaoliao,Xu Fang,Zhang Libin,et al.CFDbased simulation of the temperature in glass greenhouse with forcedair heater [J].Transactions of the Chinese Society for Agricultural Machinery,2008,39(8):114-118.（in Chinese）[8] 朱文见.冬季供暖条件下连栋温室夜间热环境的CFD模拟［D］.北京：中国农业大学水利与土木工程学院,2005.[9] 潘 强,黄之栋,马承伟,等.华北型连栋塑料温室节能对策与实践[J].农业工程学报,1999,15(2):155-159.Pan Qiang,Huang Zhidong,Ma Chengwei,et al.Study on the energy conservation of Huabei Type multi-span plastic greenhouse and its practice[J]. Transactions of CSAE,1999,15(2): 155-159.（in Chinese）［10］ 冯广和.温室的节能问题[J].农村实用工程技术：温室园艺,2004(5):23-25.Feng Guanghe.Energy saving in greenhouse[J].Rural Utility Engineering and Technology: Greenhouse Horticulture,2004(5):23-25.（in Chinese）［11］ 杨其长.荷兰温室环境调控技术进展[J].农业工程技术：温室园艺,2006(12):8-9.Yang Qichang.Progress of the Dutch greenhouse environmental control technology[J].Agricultural Engineering:Greenhouse Horticulture, 2006(12):8-9.（in Chinese）［12］ Kempkes F L K,Van de Braak N J,Bakker J C.Effect of heating system position on vertical distribution of crop temperature and transpiration in greenhouse tomatoes [J].J Agric Eng Res,2000,75(1):57-64.［13］ 王新坤,许文博,赵 坤,等.基于ＣＦＤ的多孔管热风数值模拟与设计方法[J].排灌机械工程学报,2011,29(1):82-86.Wang Xinkun,Xu Wenbo,Zhao Kun,et al.Numerical simulation and design method of hot air for porous pipe based on CFD[J].Journal of Drainage and Irrigation Machinery Engineering,2011,29(1): 82-86.（in Chinese）［14］ 王新坤.一种基于滴灌管网的温室冠层环境调控系统与方法：中国,201010603269.0 ［P］.2011-08-17.［15］ 杜建强，杨世昆，刘贵林,等．牧草太阳能低温干燥试验[J].农业机械学报,2010,41（S1）:186-190.Du Jianqiang,Yang Shikun,Liu Guilin,et al. Test on forage dryness using low temperature[J].Transactions of the Chinese Society for Agricultural Machinery, 2010,41（S1）:186-190.（in Chinese）
