Influence of muddy water mass fraction on performance of packed quartz sand bed
Deng Zhong, Zhai Guoliang, Zong Jie, Feng Junjie, Lü Mouchao, Li Ying, Cai Jiumao
Key Lab for Water-saving Agriculture of Henan Province, Farmland Irrigation Research Institute, Chinese Academy of Agricultural Sciences, Xinxiang, Henan 453002, China
Abstract：A series of experiments were conducted on performance of a filter model with packed quartz sand bed applied in micro-irrigation by using muddy water respectively with four kinds of mass fractions: 0.3‰,0.5‰,0.8‰ and 1‰ to properly evaluate effect of sediments in the muddy water on clogging in that irrigation system. In those experiments, the variation of turbidity of filtrated water, change of sand grain size as well as the relationship between sand concentration and time were mea-sured. The results showed that the mass fraction of muddy water affected the turbidity and particle concentration in filtered water; particularly, the more mass fraction, the poorer the turbidity and the hi-gher sand concentration in filtered water. The turbidity of filtered water declined gradually after a filtration was lasted for 10 minutes for the muddy water with less than 0.8‰ mass fraction; however, when the mass fraction was increased to 0.8‰, the turbidity of filtered water showed a significant fluctuation even the water had been filtered for 10 minutes. Moreover, most the particles with a size larger than 0.1 mm had stayed in the filtering bed, fortunately there still were 2%-3% large size particles that had gone through the bed. For the muddy water with a mass fraction less than 0.5‰, the mass fraction of particles with a size smaller than 0.1 mm in the filtered water increased slowly, and the fraction of particles with a size larger than 0.1 mm was less 1%. The average filtration ratio of turbidity and decrease rate of sandy particle concentration showed a quadratic relation with a negative quadratic coefficient as the mass fraction of muddy water was increased; especially they had reached 56.69% and 57.61% respectively when the mass fraction was at 0.8‰. The muddy water with a higher mass fraction had a better filtration ratio and a larger decrease rate of sand concentration, but the filter bed could be jammed easily, reducing filtering effect and shortening filtration time.
邓忠, 翟国亮, 宗洁, 冯俊杰, 吕谋超, 李迎, 蔡九茂. 浑水质量分数对石英砂滤料过滤性能的影响[J]. 排灌机械工程学报, 2013, 31(11): 1007-1012.
Deng Zhong, Zhai Guoliang, Zong Jie, Feng Junjie, Lü Mouchao, Li Ying, Cai Jiumao. Influence of muddy water mass fraction on performance of packed quartz sand bed. Journal of Drainage and Irrigation Machinery Engin, 2013, 31(11): 1007-1012.
[1]Al-Shammiri M, Al-Saffar A, Bohamad S, et al. Waste water quality and reuse in irrigation in Kuwait using microfiltration technology in treatment[J]. Desalination, 2005,185(1/2/3):213-225.[2]郑铁刚,刘焕芳,宗全利. 微灌用过滤器过滤性能分析及应用选型研究[J]. 水资源与水工程学报,2008,19(4):36-39. Zheng Tiegang, Liu Huanfang, Zong Quanli. Analysis and research for the filtering quality and type-selecting of emitter in micro-irrigation[J]. Journal of Water Resources & Water Engineering, 2008,19(4):36-39.(in Chinese)[3]颜学升,王助良,张敏,等. 新型颗粒层的过滤性能[J]. 江苏大学学报:自然科学版, 2009, 30(5): 491-495. Yan Xuesheng, Wang Zhuliang, Zhang Min, et al. Filtration performance of a new granular layer[J]. Journal of Jiangsu University: Natural Science Edition, 2009, 30(5): 491-495.(in Chinese)[4]Noubactep C, Caré S. Enhancing sustainability of household water filters by mixing metallic iron with po-rous materials[J]. Chemical Engineering Journal, 2010,162(2):635-642.[5]杨长生. 不同粒径的均质石英砂过滤性能研究[J]. 成都航空职业技术学院学报,2008,24(4):47-49. Yang Changsheng. Performance of filtration with the uniform quartz sand of different particle size[J]. Journal of Chengdu Aeronautic Vocational and Technical College, 2008, 24(4): 47-49.(in Chinese)[6]董文楚. 滴灌用砂过滤器的过滤与反冲洗性能试验研究[J]. 水利学报,1997,28(12):72-78. Dong Wengchu. A study on the filtration and backflu-shing performance of the filters with crushed quartz sand for drip-irrigation[J]. Journal of Hydraulic Enginee-ring, 1997,28(12):72-78.(in Chinese)[7]翟国亮,陈刚,赵武,等. 微灌用石英砂滤料的过滤与反冲洗试验[J]. 农业工程学报,2007,23(12):46-50. Zhai Guoliang, Chen Gang, Zhao Wu, et al. Experimental study on filtrating and backwashing of quartz sand medium in micro-irrigation filter[J]. Transactions of the CSAE, 2007,23(12):46-50.(in Chinese)[8]于玲红. 瓷砂均质滤料过滤性能的实验研究[D]. 西安:西安建筑科技大学环境与市政工程学院,2003.[9]刘璐,牛文全,Bob Zhou. 细小泥沙粒径对迷宫流道灌水器堵塞的影响[J]. 农业工程学报,2012,28(1):87-93. Liu Lu, Niu Wenquan, Bob Zhou. Influence of sediment particle size on clogging performance of labyrinth path emitters[J].Transactions of the CSAE, 2012, 28(1): 87-93.(in Chinese)[10]刘焕芳,郑铁刚,刘飞,等. 自吸网式过滤器过滤时间与自清洗时间变化规律分析[J]. 农业机械学报,2010,41(7):80-83. Liu Huanfang, Zheng Tiegang, Liu Fei, et al. Analysis of filtering time and sewage time for automatic suction screen filter[J]. Transactions of the Chinese Society for Agricultural Machinery, 2010, 41(7): 80-83.(in Chinese)[11]Committee Report. The status of direct filtration [J]. Journal AWWA, 1980, 72(7): 405-411.[12]Bucks D A, Nakayama F S, Gilbert R G. Trickle irrigation water quality and preventive maintenance[J]. Agricultural Water Management, 1979,2(2):149-162.[13]王利平,崔永亮,康文庆,等, 石英砂均质滤料过滤性能的试验研究[J]. 包头钢铁学院学报,2001,20(2):174-177. Wang Liping, Cui Yongliang, Kang Wenqing, et al. Study on the performance of filtration by uniform quartz sand media[J]. Journal of Baotou University of Iron and Steel Technology, 2001, 20(2): 174-177.(in Chinese)[14]Yang B W, Chang Q. Wettability studies of filter media using capillary rise test[J]. Separation and Purification Technology, 2008,60(3):335-340.[15]吴显斌,吴文勇,刘洪禄,等. 再生水滴灌系统滴头抗堵塞性能试验研究[J]. 农业工程学报,2008,24(5):61-64. Wu Xianbin, Wu Wenyong, Liu Honglu, et al. Experimental study on anti-clogging performance of emitters for reclaimed wastewater irrigation[J]. Transactions of the CSAE, 2008, 24(5): 61-64.(in Chinese)[16]牛文全,刘璐. 浑水泥沙粒径与含沙量对迷宫流道堵塞的影响[J]. 排灌机械工程学报,2011,29(6):547-552. Niu Wenquan, Liu Lu. Influence of muddy water concentration and particle diameter on clogging of labyrinth channels[J]. Journal of Drainage and Irrigation Machi-nery Engineering, 2011, 29(6): 547-552.(in Chinese)
